Superior Radiant S series Installation, Operation And Service Instructions

[Page 1] Superior Radiant S series

01/15 LT017 Series S Infrared Heater Installation, Operation and Service Instructions Installer Read and thoroughly understand these instructions before attempting any installation. Owner Retain this manual for reference. Improper installat...

[Page 2] Superior Radiant S series

CAUTION: FIRE OR EXPLOSION HAZARD Maintain clearance to combustible constructions as further specified in this manual. Failure to do so could result in a serious fire hazard. Heaters should not be located in hazardous a...

[Page 3] Superior Radiant S series

Series S Page - 3 - March 4, 2014 TABLE OF CONTENTS INTRODUCTION ________________________________________________________________________ 4 Installation Codes ____________________________________________________________________________ ...

[Page 4] Superior Radiant S series

Series S Page - 4 - March 4, 2014 INTRODUCTION Superior Radiant Products is a company in the infrared heating industry founded on the principles of product quality and customer commitment. Quality commitments are evidenced by superior...

[Page 5] Superior Radiant S series

Series S Page - 5 - March 4, 2014 INTRODUCTION Installation Codes Installations must comply with all local building codes or in their absence; the latest edition of the national regulations and procedures applicable to gas fired and suspend...

[Page 6] Superior Radiant S series

Series S Page - 6 - March 4, 2014 LAYOUT RECOMMENDATIONS Layout Considerations 1. Because high intensity heaters are un-vented, verify local codes for guidance on air supply and dilution air. Also see section on Ventilation. 2. Check local...

[Page 7] Superior Radiant S series

Series S Page - 7 - March 4, 2014 LAYOUT RECOMMENDATIONS Suggested heat loading for indoor spot heating under stated conditions: Ambient Air Temperature BTU/hr per sq. ft of Floor Area to be Heated At 50 ft/min of wind (15.2 m/min)...

[Page 8] Superior Radiant S series

Series S Page - 8 - March 4, 2014 B H F E C G D J A HEATER SPECIFICATIONS Figure 1: Overall Dimensional Information Dimensional Chart Natural Gas Propane Gas in cm in cm in cm in cm in cm A 16.3 41.4 23.1 58.7 30 76.2 36.9 93.7 36...

[Page 9] Superior Radiant S series

Series S Page - 9 - March 4, 2014 HEATER SPECIFICATIONS Gas Supply Natural Gas Propane Pressure Minimum 6.5 W.C. Minimum 11.0 W.C. Maximum 14.0 W.C. Maximum 14.0 W.C. Connection ½ female NPT Manifo...

[Page 10] Superior Radiant S series

Series S Page - 10 - March 4, 2014 CLEARANCE TO COMBUSTIBLES The stated clearance to combustibles represents a surface temperature of 90°F (50°C) above room temperature. Building materials with low heat tolerance (such as plastics, vinyl si...

[Page 11] Superior Radiant S series

Series S Page - 11 - March 4, 2014 INSTALLATION Gas  Figure 3 illustrate typical rigid and chain mounting configurations for the Series S heaters; verify which is permissible by local codes.  Heaters must be hung at an angle betwe...

[Page 12] Superior Radiant S series

Series S Page - 12 - March 4, 2014 If any of the original wire as supplied with the appliance must be replaced, it must be replaced with wiring material having a temperature rating of at least 105°C. Si lun des câbles dorigine fournis avec ce...

[Page 13] Superior Radiant S series

Series S Page - 13 - March 4, 2014 INSTALLATION GREEN FLAME SENSOR GAS VALVE SPARK ELECTRODE PINK GROUND ROD MV MV POWER CORD YELLOW BROWN JUNCTION BOX TRANSFORMER GREEN BLUE If any of the original wire as supplied with the appli...

[Page 14] Superior Radiant S series

Series S Page - 14 - March 4, 2014 VENTILATION / CONDENSATION Ventilation Buildings using high intensity radiant heaters require ventilation. High Intensity type heaters are considered un-vented gas fired appliances, requiring ventilation to ...

[Page 15] Superior Radiant S series

Series S Page - 15 - March 4, 2014 OPERATION / MAINTENENCE Operation Ensure the gas supply line has been purged. Open all gas cocks to the heaters and electrically energize the system. Follow the instructions on the heaters Lighting Inst...

[Page 16] Superior Radiant S series

Series S Page - 16 - March 4, 2014 TROUBLESHOOTING Symptom Possible Cause Corrective Acton Heaters will not turn off Defective thermostat Stuck solenoid valve Repair or replace Repair or replace Gas Odor Loose pipe connectio...

[Page 17] Superior Radiant S series

Series S Page - 17 - March 4, 2014 PARTS Figure 6: Replacement Parts ELECTRODE ASSEMBLY (P/N SE001) IGNITION WIRE (P/N CE006) IGNITION MODULE (P/N CE109) TRANSFORMER (P/N SE004) BURNER HEAD ASSEMBLY (P/N SG009) GAS VALVE (P/N SG003 - N...

[Page 18] Superior Radiant S series

Series S Page - 18 - March 4, 2014 WARRANTY SERIES S INFRARED HEATERS WARRANTY The Manufacturer warrants to the original owner that the product will be free of defects in material and workmanship. For the Series S, the warranty for ...