Zodiac ROUND POOL 1" RIMS Instrucitons

[Page 1] Zodiac ROUND POOL 1" RIMS

© 2004 ZODIAC AMERICAN POOLS, INC. ALL RIGHTS RESERVED • MADE IN U.S.A. DECEMBER 2, 2003 English Round Pool 1" Rims CAUTION: Read all instructions carefully before starting the installation. Check for missing parts by reviewing the Replace-...

[Page 2] Zodiac ROUND POOL 1" RIMS

2 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) SAFETY INSTRUCTIONS As the owner, you have the most important role in reminding users of pool safety. You must set a safety example for your family and guests. Use common sense around your pool and ...

[Page 3] Zodiac ROUND POOL 1" RIMS

3 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) FAILURE TO HEED THESE WARNINGS CAN RESULT IN SERIOUS INJURY OR PROPERTY DAMAGE. NO HORSEPLAY • Never allow horseplay in or around the pool. POOL CHEMICALS • Do not place chlorine, chlorine table...

[Page 4] Zodiac ROUND POOL 1" RIMS

4 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) DETERMINE POOL LOCATION NO NO NO YES ALWAYS DIG AWAY TO LEVEL THE SURFACE DO NOT INSTALL POOL BELOW GROUND LEVEL 1. READ INSTRUCTIONS Take your time and read these instructions thoroughly before you...

[Page 5] Zodiac ROUND POOL 1" RIMS

5 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) Think of your above ground pool as a big dam. If the pool is out of level or if the wall is worn or damaged, the uneven pressure can cause the wall to break or tip and allow thousands of gallons of ...

[Page 6] Zodiac ROUND POOL 1" RIMS

6 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) If you have purchased a hopper liner, see special excavation instructions in liner carton. Using the chart below and FIG. 1, mark off pool area as shown. a. Drive a stake into ground at approximate ...

[Page 7] Zodiac ROUND POOL 1" RIMS

7 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) ASSEMBLE CIRCULAR BOTTOM FRAMEWORK a. Form the circular of rims and foot plates as shown in Figure 4. Snap rims into foot plates engaging all tabs as shown in Figure 5. b. Measure the distance fro...

[Page 8] Zodiac ROUND POOL 1" RIMS

8 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) HINT: Place the sifted earth and sand inside the circle of rims before installing the pool wall (Step 4). CARPENTER'S LEVEL 2 x 4 PLANK 2" CONCRETE BLOCK 2" BLOCK OF WOOD CENTER STAKE...

[Page 9] Zodiac ROUND POOL 1" RIMS

9 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) a. Set coiled pool wall on a plywood inside the pool area (FIG. 9). The perforated knockouts in the wall are for an optional thru-the-wall skimmer. Whether a skimmer is used or not, these knockout...

[Page 10] Zodiac ROUND POOL 1" RIMS

10 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) a. Build an 8" cove of firmly packed masonry sand around the inside base of the pool frame (FIG. 12). USE DAMPENED SAND ONLY! DO NOT USE PEAT MOSS OR ANY TYPE “POOL BASE” MATERIAL*. Th...

[Page 11] Zodiac ROUND POOL 1" RIMS

11 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) BE SURE: Liner is heavy - do not attempt to install it yourself. Pull liner gently - avoid sharp tugs. Do not cut or trim edges of liner. All seams must be straight. The bottom round seam should be...

[Page 12] Zodiac ROUND POOL 1" RIMS

12 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) CAUTION: • Liner is heavy-do not attempt to install it yourself. • Pull liner gently-avoid sharp tugs. • Do not cut or trim edges of liner. • All seams must be straight. • The bottom roun...

[Page 13] Zodiac ROUND POOL 1" RIMS

13 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) TOP PLATE a. Fasten uprights to foot plates with three #10 x 1/2" sheet metal screws. (FIG. 18) b. (FIG. 18:) Hook the back flange of the top plate over the wall stabilizer. Fasten sides of ...

[Page 14] Zodiac ROUND POOL 1" RIMS

14 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) TOP LEDGE - 12' THRU 27' POOLS TOP LEDGE - 12' POOLS TOP VIEW TOP LEDGES WITH NO DIVING DECALS MUST BE INSTALLED IN THESE LOCATIONS NO DIVING DECAL ATTACHED TO FOUR TOP LEDGES DESI...

[Page 15] Zodiac ROUND POOL 1" RIMS

15 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) Your 9" x 11" NO DIVING sign must be posted in plain sight near your pool entry/exit location to remind pool users of the importance of this safety information. If you are not installing ...

[Page 16] Zodiac ROUND POOL 1" RIMS

16 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) BE SURE: Follow all safety instructions in the special safety section packed with these assembly instructions. It is important to follow necessary health regulations concerning chlorination, circul...

[Page 17] Zodiac ROUND POOL 1" RIMS

17 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) a. Use a leaf skimmer to remove debris. b. Reinstall the filter and run continuously. Watch pressure carefully and clean filter when necessary. 2. How to Prepare Your Pool for Spring 3. General M...

[Page 18] Zodiac ROUND POOL 1" RIMS

18 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) 9 10 11 13 14 1 6 5 4 15 15 17 16 1 2 3 KEY FOR REPLACEMENT PARTS 7 17 7 8 SLOT ON UPRIGHT 12 1 11 ...

[Page 19] Zodiac ROUND POOL 1" RIMS

19 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) REPLACEMENT PARTS P/N QTY P/N QTY P/N QTY P/N QTY P/N QTY P/N QTY P/N QTY 1 76511 110 76511 102 76511 110 76511 130 76511 150 76511 170 76511 190 #10x1/2" Sheet Metal Screw 2 02960 11 02187 9...

[Page 20] Zodiac ROUND POOL 1" RIMS

20 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) HOW TO ORDER REPLACEMENT PARTS If you find any of the parts missing or defective or if you cannot identify a problem, do not take the package or any part of the package back to the place of purchas...

[Page 21] Zodiac ROUND POOL 1" RIMS

21 97206DECEMBER 2, 2003 (Round Pool - 1" Rims) 15 Season Limited Warranty15 Season Limited Warranty POOL FRAME & WALL Zodiac American Pools, Inc. (ZAP) warrants to the original purchaser only, all metal parts to be rust resistan...