Travis Industries 6015 HO Owner's Manual

[Page 1] Travis Industries 6015 HO

6015 HO GreenSmart™ 2 Fireplace  Operation  Maintenance Listed by AS 4553-2008 GMK 10166 IAPMO-R&T OCEANA WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causi...

[Page 2] Travis Industries 6015 HO

2 Introduction © Travis Industries 4131220 100-01371 Introduction We welcome you as a new owner of a 6015 HO gas fireplace. This manual details operation and maintenance of this fireplace. Please familiarize yourself with the Owner's Man...

[Page 3] Travis Industries 6015 HO

Introduction 3 © Travis Industries 4131220 100-01371 Table of Contents  Introduction ................................................... 2 Important Information ................................... 2 Installation Warnings ............

[Page 4] Travis Industries 6015 HO

4 Safety Precautions © Travis Industries 4131220 100-01371 IF YOU SMELL GAS: * Do not light any appliance * Extinguish any open flame * Do not touch any electrical switch or plug or unplug anything * Open windows and vacate building * Cal...

[Page 5] Travis Industries 6015 HO

Safety Precautions 5 © Travis Industries 4131220 100-01371 Do not place clothing or other flammable items on or near the heater. Because this heater can be controlled by a thermostat there is a possibility of the heater turning on and...

[Page 6] Travis Industries 6015 HO

6 Operation © Travis Industries 4131220 100-01371 Before You Begin  Read this entire manual before you use your new fireplace (especially the section "Safety Precautions" on pages 4 & 5). Failure to follow the instructions m...

[Page 7] Travis Industries 6015 HO

Operation 7 © Travis Industries 4131220 100-01371 Remote Set-Up Verify the Switch is on “REMOTE” The battery holder has a switch built into it (see Figure 1). This switch must remain in the REMOTE position for the remote to operate. F...

[Page 8] Travis Industries 6015 HO

8 Operation © Travis Industries 4131220 100-01371 Starting the Heater for the First Time  Burn the heater at a low setting with the blower off for an extended period (up to 48 hours). This will cure the painted surfaces. Fumes from the p...

[Page 9] Travis Industries 6015 HO

Operation 9 © Travis Industries 4131220 100-01371 Continuous/Intermittent Pilot Switch This heater may run with the pilot continuously running or in Intermittent mode. For most homeowners, Intermittent mode is preferable (this saves fuel, doe...

[Page 10] Travis Industries 6015 HO

10 Operation © Travis Industries 4131220 100-01371 Remote Operation When the switch on the battery holder is set to “REMOTE” the transmitter operates the fireplace. Once you understand how the transmitter works, you will be able to opera...

[Page 11] Travis Industries 6015 HO

Operation 11 © Travis Industries 4131220 100-01371 Manual On-Off / Smart Thermostat / Standard Thermostat Use the thermostat button to cycle through the three thermostat settings (see Figure 5). Figure 5  MANUAL ON/OFF – The burner w...

[Page 12] Travis Industries 6015 HO

12 Operation © Travis Industries 4131220 100-01371 Mode Controls (Flame, Blower, Light) Press the Mode button to cycle through the four mode controls (see Figure 9 below). Figure 9 Flame Height Flame height may be controlled using the UP ...

[Page 13] Travis Industries 6015 HO

Operation 13 © Travis Industries 4131220 100-01371 Mode Controls (continued) Accent Light The Accent Light (night light) inside the heater may be turned on and off using the up and down buttons when in Accent Light mode (see Figure 13). The...

[Page 14] Travis Industries 6015 HO

14 Operation © Travis Industries 4131220 100-01371 Battery Replacement Battery Installation Install four AA batteries into the battery holder (see below). These batteries act as a power backup in case the household (AC) current goes out. Tra...

[Page 15] Travis Industries 6015 HO

Operation 15 © Travis Industries 4131220 100-01371 Child-Proof Feature The child-proof feature disables the control buttons, preventing unwanted use of the remote.  Press both the MODE and UP buttons simultaneously to turn this feature...

[Page 16] Travis Industries 6015 HO

16 Maintenance © Travis Industries 4131220 100-01371 Yearly Service Procedure Failure to inspect and maintain the heater may lead to improper combustion and a potentially dangerous situation. We recommend the following procedures be done ...

[Page 17] Travis Industries 6015 HO

Maintenance 17 © Travis Industries 4131220 100-01371 Accent Light Replacement The accent lights in your heater provide additional lighting. The bulbs will burn out over time. To replace, follow the directions below:  Shut off gas to t...

[Page 18] Travis Industries 6015 HO

18 Maintenance © Travis Industries 4131220 100-01371 Glass Frame Removal and Installation Do not remove the glass frame with the screen attached – it will not disengage correctly and may damage the screen. The appliance must be comple...

[Page 19] Travis Industries 6015 HO

Maintenance 19 © Travis Industries 4131220 100-01371 2. Remove the three screws holding the screen in place (1/4” nutdriver- magnetic driver recommended). Then pivot the screen down slightly until the clips on the bottom disengage from the...

[Page 20] Travis Industries 6015 HO

20 Maintenance © Travis Industries 4131220 100-01371 Crushed Glass Installation Do not allow the crushed glass to block the air slots or to become too thick (maximum 1 layer deep on the burner). Failure to properly install glass may lead to...

[Page 21] Travis Industries 6015 HO

Maintenance 21 © Travis Industries 4131220 100-01371 Glass Cleaning The glass may be cleaned with a non- abrasive cleaner. To clean the inside of the glass, simply remove the glass frame, place it on a non-scratching surface, and clean th...

[Page 22] Travis Industries 6015 HO

22 Maintenance © Travis Industries 4131220 100-01371 Troubleshooting Table Problem: Possible Cause: Don't Call for Service Until You: Burner Will Not Start The battery box switch is turned to "OFF" The remote control ...

[Page 23] Travis Industries 6015 HO

Maintenance 23 © Travis Industries 4131220 100-01371 Wiring Diagram Caution: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Replacement Parts List Caution: Use ...

[Page 24] Travis Industries 6015 HO

24 Limited 7 Year Warranty © Travis Industries 4131220 100-01371 Register your Dragon Wholesaling Limited 7 Year Warranty online at lopi.com.au or complete the enclosed Warranty card and mail it within ten (10) days of the appliance purchase d...

[Page 25] Travis Industries 6015 HO

Limited 7 Year Warranty 25 © Travis Industries 4131220 100-01371 ...

[Page 26] Travis Industries 6015 HO

26 Index © Travis Industries 4131220 100-01371 Index Accent Light Replacement ............................... 17 Battery Replacement ........................................ 14 Before You Begin ...............................................