Hearthstone 8762 User Manual

[Page 1] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. ® Bristol DX Model 8762 Manual: 6400-40466 R: 1/4/2012 Bristol DX (Model 8762) GAS-FIRED DIRECT-VENT HEATER Owner's Manual Installation & Operating Instructions Read This Manu...

[Page 2] HearthStone 8762

Intentionally Blank ...

[Page 3] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 3 Information Sheet Use this page to record all relevant information concerning the purchase, installation, and maintenance of your Bristol DX Model 8762 Direct -Vent heate...

[Page 4] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 4 Table of Contents INTRODUCTION ...............................................................................................................................................

[Page 5] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 5 Introduction Congratulations on your purchase of the Bristol DX Model 8762, Gas-Fired Direct-Vent heater. The Bristol, by Hearthstone, incorporates the latest in direct...

[Page 6] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 6 Safety Information Your Bristol is an attractive and extremely efficient and easy to use heater, utilizing today’s best technologies. By following a few simple safety ...

[Page 7] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 7 (S’ASSURER QUE LE BRÛLEUR ET LE COMPARTIMENT DES COMMANDES SONT PROPRES. VOIR LES INSTRUCTIONS D’INSTALLATION ET D’UTILISATION QUI ACCOMPAGNENT L’APPAREIL.) ...

[Page 8] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 8 Proflame Control System & Features NOTE: OPEN DOOR UNDER THE ASH LIP AND DROP DOWN THE MODESTY PANEL FOR ACCESS TO ELECTRICAL AND GAS CONNECTIONS. Bristol DX 876...

[Page 9] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 9 not available, neither the FCM nor the blower will operate. The FCM is equipped with a three-prong (grounding) plug for protection against shock hazard and should be p...

[Page 10] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 10 Control Functions Pilot Mode Continuous Pilot (CPI): Running the Bristol 8762 in CPI mode will keep your pilot on even when the thermostat does not call for heat and wh...

[Page 11] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 11 Remote Transmitter Figure 7 - Remote Transmitter Function Keys (remote color may differ from shown) ON/OFF Key: Controls the main burner, blower, and the modulati...

[Page 12] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 12 Specifications L ISTED : Gas-Fired Direct-Vent Fireplace Heater Model: Bristol Direct-Vent Gas Fireplace Heater (8762) Testing Agency: Intertek Testing Services NA...

[Page 13] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 13 Installation Preparation Codes Adhere to all local codes or, in their absence, the latest edition of THE NATIONAL FUEL GAS CODE ANSI Z223.1 (NFPA 54) or CAN/CGA B149 ...

[Page 14] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 14 damage is found or suspected, contact your dealer for instructions. Always use gloves and eye protection when handling the decorative ceramic fire logs, and burner. Us...

[Page 15] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 15 Firebox Access 1. First, remove the top of the stove (lift off). Set carefully aside on a soft surface. 2. Lift the front panel slightly to disengage the tangs at ...

[Page 16] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 16 Clearances to Combustibles Note: Ensure clearances are in accordance with local installation codes and the requirements of the gas supplier. Clearance to Combustibl...

[Page 17] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 17 The corner clearance for the Bristol 8762 is 11”, measured from the edge of the top castings, to the adjacent wall. Figure 17 - Corner Clearance ...

[Page 18] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 18 Venting Information Venting Components Starter collar is installed by Hearthstone. Use the following instructions along with the pipe manufacturer’s instructions to...

[Page 19] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 19 All termination caps must be no less than 18” (457mm) horizontally from any roof or vertical surface. See Figure 18. The termination must fall within the chart i...

[Page 20] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 20 Horizontal Termination The termination must fall within the area shown in Figures 18 & 20. A minimum of 36" rise is required either directly off the heate...

[Page 21] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 21 Figure 20 - Acceptable Direct Vent Terminal Vent Cap Locations A = Clearance above grade, veranda, porch, deck, or balcony: 12 inches (30cm) minimum. B = Clear...

[Page 22] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 22 Minimum Venting Installation Instructions 1. Install the 36” pipe section onto the starter collar by fully inserting it and turning approximately ¼ turn clockwise...

[Page 23] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 23 Restrictor Plate The restrictor plate is used to control excess draft if necessary. Controlling the draft also changes the aesthetics of the flame. The restrictor plate...

[Page 24] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 24 Figure 24 - Venting Termination Diagram ...

[Page 25] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 25 Electrical System Information CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS OPERATION. VERIF...

[Page 26] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 26 Gas Supply & Connections NOTE: Ensure the gas line is installed as close to the floor as possible to avoid interference or conflict with a blower assembly install...

[Page 27] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 27 Gas Connections The gas supply connection is made to the Bristol’s gas control valve under the bottom left center of the unit using a 3/8” male NPT fitting. The su...

[Page 28] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DX Model 8762 28 Log Set, & Screen Placement CAUTION: FRAGILE! HANDLE LOG SET WITH CARE. ALWAYS WEAR GLOVES AND SAFETY GOGGLES WHILE HANDLING THE LOG SET. WARNING: Failure...

[Page 29] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol DV Model 8762 29 5. Place log 4 on top of logs 1 as shown. Photo 5 – Log 4 in Position 6. Gently place Log 5 in the indentati...

[Page 30] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 30 Lighting & Operation WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY R...

[Page 31] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 31 Figure 29 - Pilot Flame Pattern WARNING: THE CONTROL HAS AN INTERLOCK DEVICE. IF THE STOVE HAS BEEN LI...

[Page 32] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 32 Note: Very little movement is needed to substantially change the burn and flame patterns. Some conditions ca...

[Page 33] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 33 To Turn off Gas and Shut Down the Appliance: 1. Close the shut-off in the gas supply to the valve. 2. Set t...

[Page 34] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 34 Routine Maintenance & Care Your Bristol requires minimal routine maintenance and care. Ensure the unit is co...

[Page 35] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 35 Battery Replacement WARNING: DISCONNECT POWER TO THE UNIT AND SHUT OFF THE GAS SUPPLY TO THE VALVE BEFORE RE...

[Page 36] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 36 3. Dismount the front glass assembly by releasing the upper spring clips – then lift the frame up and out of...

[Page 37] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 37 Parts List Part # Description Part # Description 27XX-740 Top 5710-307 Pilot Shield 27XX-730 Front 5710-...

[Page 38] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 38 Troubleshooting Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Power supply not pl...

[Page 39] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 39 Symptom Possible Cause Corrective Action 5. Frequent pilot outage problem in CPI mode. A. Pilot flame may ...

[Page 40] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 40 Rating Label ...

[Page 41] HearthStone 8762

Hearthstone Quality Home Heating Products, Inc. Bristol Model 8762 41 WARRANTY REGISTRATION The Original Purchaser can complete their warranty registration on our website at www.hear...