Bosch UHO-HBPS Installation Manual

[Page 1] Bosch UHO-HBPS

UHO Camera Housing UHO-HBPS | UHO-HBGS | UHO-HGS | UHO-HPS en Installation Manual ...

[Page 2] Bosch UHO-HBPS

...

[Page 3] Bosch UHO-HBPS

Table of contents 1 Safety 4 1.1 Safety message explanation 4 1.2 Safety precautions 4 1.3 Important safety instructions 5 1.4 FCC and ICES compliance 6 2 Short information 7 3 System overview 8 3.1 Available models 8 4 Planning information 9 4.1 Par...

[Page 4] Bosch UHO-HBPS

Safety Safety message explanation Danger! Indicates a hazardous situation which, if not avoided, will result in death or serious injury. ! Warning! Indicates a hazardous situation which, if not avoided, could result in death or serious injury. ! ...

[Page 5] Bosch UHO-HBPS

Important safety instructions Read, follow, and retain for future reference all of the following safety instructions. Follow all warnings before operating the unit. 1. Clean only with a dry cloth. Do not use liquid cleaners or aerosol cleaners. 2. Do...

[Page 6] Bosch UHO-HBPS

FCC and ICES compliance FCC & ICES Information (U.S.A. and Canadian Models Only) This device complies with part 15 of the FCC Rules. Operation is subject to the following conditions: – this device may not cause harmful interference, and – thi...

[Page 7] Bosch UHO-HBPS

Short information This manual has been compiled with great care and the information it contains has been thoroughly verified. The text was correct at the time of printing, however, the content can change without notice. Bosch Security Systems accepts...

[Page 8] Bosch UHO-HBPS

System overview Available models These outdoor camera housings are available in several versions. The variants are input power supply, fitted connectors and temperature control. All models are equipped with a heater and a sunshield. The maximum camer...

[Page 9] Bosch UHO-HBPS

Planning information Parts list Quantity Item Material 1 Housing Aluminum 1 Spacer, 4 mm ABS 1 Spacer, 9 mm ABS 1 Screw, 1/4-20 x 3/8 in. Stainless Steel 1 Screw, 1/4-20 x 3/4 in. Stainless Steel 3 Screw, tamper-resistant M3.5 T15 1 Wrench, tamper-re...

[Page 10] Bosch UHO-HBPS

Unpacking This equipment should be unpacked and handled with care. If an item appears to have been damaged in shipment, notify the shipper immediately. Verify that all parts are included. If any items are missing, notify your Bosch Security Systems S...

[Page 11] Bosch UHO-HBPS

Installation ! Caution! Installation should only be performed by qualified service personnel in accordance with the National Electrical Code (NEC 800 CEC Section 60) or applicable local codes. ! Caution! These units must be properly and securely ...

[Page 12] Bosch UHO-HBPS

Housing mounting 1. Use two 1/4-20 x 0.50 in. screws and two 1/4 in. spring washers to mount the housing to a mount or a pan/tilt. The spring washers must be used for a secure connection. 2. The outermost set of 1/4-20 threaded holes (2) are for moun...

[Page 13] Bosch UHO-HBPS

Feed-through cables Feed-through power cables Power into the housings must be supplied using type UL Standard SJ cord (or better) acceptable for outdoor use. Installation must conform to NEC 400-4 CEC rule 4-010 and be marked with OUTDOOR, W, or W-A....

[Page 14] Bosch UHO-HBPS

Camera/Lens installation Camera tray mount 1. Loosen the two screws holding the camera tray in the housing. Slide the tray backwards and remove from the housing. 2. Attach the lens to the camera. (If the lens length can vary, make sure that it is ful...

[Page 15] Bosch UHO-HBPS

Mounting the camera/tray in the housing 1. Slightly tilt the camera/lens tray assembly and slide it in under the rail that is located under the heater on the right side of the housing. 2. Lower the tray so that the holes at the side fit over the tw...

[Page 16] Bosch UHO-HBPS

Connection Feed-through power connection ! Caution! To protect the device, the branch circuit protection must be secured with a maximum fuse rating of 16A. This must be in accordance with NEC 800 (CEC Section 60). ! Caution! The external ground w...

[Page 17] Bosch UHO-HBPS

Incoming power wires The terminal block accepts wire ranging from 0.5 mm² to 2.5 mm² (20 AWG to 14 AWG). When using larger wire sizes, splice to a smaller size wire at the terminal block end. The splice may need to be enclosed in a junction box if ...

[Page 18] Bosch UHO-HBPS

Camera connections Camera video connections Connect the video (and data) cable directly to the camera. Camera power connections Connect power to the camera as follows (refer to wiring diagram): – For 12 VDC cameras: – Connect the DC12V OUT connec...

[Page 19] Bosch UHO-HBPS

Housings with rear connectors Connection – UHO – Rear housing video connection A BNC connector is provided on the rear of the housing. Connect the analog video cable to this connector. Connection – UHO – Rear housing power connection The hous...

[Page 20] Bosch UHO-HBPS

Final assembly Camera operation ! Warning! Hazardous voltage Use caution when working inside the housing. Hazardous voltage is present in the housing when connected to the AC supply. Do not touch the power terminals when the unit is powered. Verify...

[Page 21] Bosch UHO-HBPS

Maintenance No special maintenance is required other than occasionally cleaning the window. The window can be cleaned with water or any non-aggressive liquid. Fuse replacement 1. To replace a fuse, push and twist the fuse holder to open it. 2. Replac...

[Page 22] Bosch UHO-HBPS

Decommissioning The unit should only be passed on together with this installation guide. Disposal - Your Bosch product was developed and manufactured with high-quality material and components that can be recycled and reused. This symbol means that el...

[Page 23] Bosch UHO-HBPS

...

[Page 24] Bosch UHO-HBPS

Bosch Security Systems B.V. Torenallee 49 5617 BA Eindhoven The Netherlands www.boschsecurity.com © Bosch Security Systems B.V., 2014 ...