Holman QCSe-3 SERIES Installation And Operation Instructions Manual

Download or browse on-line these Installation And Operation Instructions Manual for Holman QCSe-3 SERIES Toaster.

Holman QCSe-3 SERIES Manual Information:

This manual for Holman QCSe-3 SERIES, given in the PDF format, is available for free online viewing and download without logging on. The guide contains 20 pages, and the size of the file at download is . The document type is Installation And Operation Instructions Manual.

Download Manual

More Manuals:

In case you failed to obtain relevant information in this document, please, look through related operating manuals and user instructions for Holman QCSe-3 SERIES. Just click one of the links below to go to the selected manual:

Summary of Contents:

[Page 1] Holman QCSe-3 SERIES

1 ® CONVEYOR TOASTER MODEL QCSe-2, QCSe-3 SERIES Installation and Operation Instructions 2M-HG0653 Rev. E 1/26/2006 QCSe-2 ...

[Page 2] Holman QCSe-3 SERIES

2 2 These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. RETAIN THIS MANUAL FOR FUTURE REFERENCE NOTICE Using any part other than genuine Star...

[Page 3] Holman QCSe-3 SERIES

3 SPECIFICATIONS: QCSe2-300H Type: Conveyor Toaster w/ Electronic Controls 120V, 1,700 watts, 14.1 amp, 60 hz, NEMA 5-15P Product Opening: 3" inches Approximate shipping weight - 64 lbs (140.8 kg) ...

[Page 4] Holman QCSe-3 SERIES

4 GENERAL INSTALLATION DATA CAUTION This equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general pu...

[Page 5] Holman QCSe-3 SERIES

5 WARNING DO NOT CUT OR REMOVE THIS PLUG OR GROUNDING PRONG FROM THE PLUG. WARNING CONNECT/PLUG UNIT INTO DEDICATED A.C. LINE ONLY SPECIFIED ON THE DATA PLATE OF THE UNIT. DAILY OPERATION The Holman QCSe conveyor toaster comes with pre-prog...

[Page 6] Holman QCSe-3 SERIES

6 CAUTION CERTAIN SURFACES ARE EXTREMELY HOT DURING OPERATION AND CARE SHOULD BE TAKEN WHILE USING THIS UNIT. START UP When the toaster has been plugged into a suitable outlet and power supply, the word OFF will be displayed on the L.E.D. read ...

[Page 7] Holman QCSe-3 SERIES

7 PROGRAMING A. CONVEYOR SPEED (temporary setting) The conveyor speed is programmable with a range from 0 to 99 with 0 being the slowest and 99 being the fastest. Each menu item can have independent conveyor speed settings. The LIGHT and DARK butto...

[Page 8] Holman QCSe-3 SERIES

8 CLEANING Preventive maintenance for your Holman toaster consists of the following recommended cleaning procedures. To keep your toaster in its top operating condition, these steps should be performed on a daily or weekly as indicated. A. Clean...

[Page 9] Holman QCSe-3 SERIES

9 MAINTENANCE PROCEDURES A. REPLACING HEATER TUBES 1) DISCONNECT UNIT FROM POWER SOURCE. 2) Remove the enclosure. 3) Remove heater tube wire from terminal block connection, keeping top and bottom wires separate. 4) Lift heater tube re...

[Page 10] Holman QCSe-3 SERIES

10 TROUBLESHOOTING GUIDE A. UNIT WILL NOT HEAT, CONVEYOR BELT WILL NOT MOVE. 1) Be sure the main circuit breaker is switched to the ON position. 2) Check to see if the toaster is plugged in and all controls are turned to the ON position. B. ...

[Page 11] Holman QCSe-3 SERIES

11 Part# 2M-4497-2 12/06 RMS The foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty. FOR ASSISTANCE Should you need any assistance regarding the Operation or Maintenance of any Star ...

[Page 12] Holman QCSe-3 SERIES

12 QCSe OT1 HT1 HB1 F1 M1 L1 120V OT2 F2 L2 M2 120V 240V 240V HT2 HB2 TOP HEAT BOTTOM HEAT BLU ORG PUR BLK ORG BLU POWER BOARD BRN BLK BLK BLK PUR BRN FAN MOTOR DRIVE MOTOR HIGH/LIMIT RESET STAR MANUFACTURING INTERNATIONAL INC. 065270 06-19-03...

[Page 13] Holman QCSe-3 SERIES

13 TOP HEAT BOTTOM HEAT QCSe OT1 HT1 HB1 F1 M1L1 120V OT2 F2 L2 M2 120V 240V 240V HT2 HB2 ORG HIGH/LIMIT RESET ORG BLU BLU PUR BLK BRN BLK PUR BLK BLK BRN FAN MOTOR DRIVE MOTOR POWER BOARD CONTROL BOARD STAR MANUFACTURING INTERNATIONAL INC. 0...

[Page 14] Holman QCSe-3 SERIES

14 2 33 26 15 11 12 1 3 4 5 6 7 8 9 13 10 7 28 14 35 16 17 18 19 21 22 23 24 30 34 20 25 27 31 29 MODEL: QCSe CONVEYOR TOASTER THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. NO REPRODUCTION OR DISCLOSURE OF ITS CONTENT...

[Page 15] Holman QCSe-3 SERIES

15 PARTS LIST January 26, 2006, Rev E QCSe-2-300H, QCSe-2-500 Conveyor Toasters IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE INCLUDE MODEL AND SERIAL NUMBER ...

[Page 16] Holman QCSe-3 SERIES

16 1 HC-101370 1 ENCLOSURE, QCS2 2 HC-100570 1 BAFFLE, AIR FLOW HI QCSe-2-600 2 HD-100571 1 BAFFLE, AIR FLOW LOW QCSe-2-800 3 HF-402449 1 PANEL, BACK, QCS2 4 2U-200560 1 MOTOR, FAN 5 HI-115071 1 MOTOR, DRIVE, FAN, W T...

[Page 17] Holman QCSe-3 SERIES

17 IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED PAGE INCLUDE MODEL AND SERIAL NUMBER OF 1 HH-101371 1 ENCLOSURE, QCS3 2 HH-100572 1 BAFFLE, AIR FL...

[Page 18] Holman QCSe-3 SERIES

18 Number Per Unit Description Part Number Key Number 1 HH-101371 1 ENCLOSURE, QCS3 2 HD-100573 1 BAFFLE, AIR FLOW, LOW 3 HH-402470 1 PANEL, BACK, QCS3 4 2U-200561 1 MOTOR, FAN 5 HI-115071 1 MOTOR, DRIVE...

[Page 19] Holman QCSe-3 SERIES

...

[Page 20] Holman QCSe-3 SERIES

STAR MANUFACTURING 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (800) 807-9054 (314) 781-2777 Parts & Service (800) 807-9054 www.star-mfg.com ...