Minuteman PRO-E User Manual

[Page 1] Minuteman PRO-E

User's Manual PRO-E SERIES ...

[Page 2] Minuteman PRO-E

1 © Copyright Para Systems, Inc., 2003 PRO-E Series User's Manual 1. Introduction 2 2. Controls and Indicators 5 3. Installation 7 4. Operation 9 5. Troubleshooting 12 6. Replacing the Battery 13 7. Obtaining Service 16 8. Specifications 17 9...

[Page 3] Minuteman PRO-E

2 IMPORTANT SAFETY INSTRUCTIONS SAVE THESE INSTRUCTIONS ! English Thank you for purchasing a MINUTEMAN power protection product. It has been designed and manufactured to provide many years of trouble free service. Please read this manual before insta...

[Page 4] Minuteman PRO-E

3 WARNING: Risk of Electrical Shock. Hazardous live parts inside these power supplies are energized from the battery even when the AC input is disconnected. To de-energize the outputs of the UPS: 1. If the UPS is on press and release the On/Off/Tes...

[Page 5] Minuteman PRO-E

4 English Para Systems Life Support Policy As a general policy, Para Systems Inc. (Para Systems) does not recommend the use of any of its products in life support applications where failure or mal- function of the Para Systems product can be reasonab...

[Page 6] Minuteman PRO-E

5 On-Line On-Battery Buck Boost English On-Line/On-Battery/Boost/Buck LED Overload LED Weak/Bad Battery LED On/Off/Test Button Fault LED Press and release the ON/OFF/Test Button after 1 beep to turn the UPS ON or OFF (see section 4). The On-Lin...

[Page 7] Minuteman PRO-E

6 REAR PANEL English 5 4 3 2 1 10 8 6 7 9 5 4 3 2 1 8 6 7 9 1. The Information/Rating Label. 2. The Battery Backup and Surge output power receptacles are NEMA 5-15R type (IEC 320 C13 sockets for 230V models). 3. The USB Communications Interface P...

[Page 8] Minuteman PRO-E

7 INSTALLATION PLACEMENT The PRO-E series is intended to be install in a temperature controlled environ- ment that is free of conductive contaminants. Select a location which will pro- vide good air circulation for the UPS at all times. Avoid locatio...

[Page 9] Minuteman PRO-E

8 English DO NOT plug Power Strips or Surge Protection Devices into the ”Battery Backup” Receptacles on the UPS. Plugging Power Strips or Surge Protection Devices into the “Battery Backup” Receptacles may cause internal damage to the UPS, th...

[Page 10] Minuteman PRO-E

9 English TURNING THE UNIT ON/OFF ON / OFF / Test Button SELF TEST Press and release the ON/OFF/Test Button after one beep to turn the UPS ON and supply power to the load. The load is immediately powered while the UPS runs a two-second self test. P...

[Page 11] Minuteman PRO-E

10 English ALARMS ON BATTERY When the UPS is operating on the batteries, the On-Battery LED will blink and the audible alarm will sound once every 10-seconds. The alarm will stop once the UPS returns to the On-Line operation. UPS FAULT When the UPS ...

[Page 12] Minuteman PRO-E

11 COMMUNICATIONS PORTS (RS232 and USB) The RS232 communication port is a standard DB9 female with both RS232 and simulated contact closure capability. The PRO-E series UPS will poll the port and activate the port for RS232 or contact closure in acc...

[Page 13] Minuteman PRO-E

12 English Possible Cause Symptom What To Do Press and release the On/Off/ Test button to start UPS On/Off/Test button not pushed UPS will not turn on Reset circuit breaker by pressing the plunger back in. If the AC circuit breaker trips after UPS st...

[Page 14] Minuteman PRO-E

13 REPLACING THE BATTERY WARNING! This Uninterruptible Power Supply contains potentially hazardous voltages. Do not attempt to disassemble the UPS beyond battery replacement procedures below. This UPS contains no user serviceable parts. Repairs and...

[Page 15] Minuteman PRO-E

14 English BATTERY REPLACEMENT PROCEDURE PLEASE READ THE CAUTIONS AND WARNINGS BEFORE ATTEMPTING TO REPLACE THE BATTERIES Hot-swappable batteries mean that the batteries can be replaced without powering down the whole UPS system. NOTE: If there is a...

[Page 16] Minuteman PRO-E

15 9. Disconnect the positive (red) wire from the battery positve terminal. 10. Disconnect the battery negative (black) wire from the battery negative terminal. NOTE: Use CAUTION, do not touch the battery positive wire to the battery negative ...

[Page 17] Minuteman PRO-E

16 English IF THE UPS REQUIRES SERVICE 1.Use the TROUBLESHOOTING section to eliminate obvious causes. 2.Verify there are no circuit breakers tripped. A tripped circuit breaker is the most common problem. 3.Call your dealer for assistance. If you c...

[Page 18] Minuteman PRO-E

17 Default 120V (230V) / User selectable at 120/127V, (208/230V) 3-5 years, depending on discharge cycles and ambient temp 500VA 350W 700VA 490W 1500VA 1050W 1100VA 770W 500 J (440 J) 0 ns (instantaneous) normal mode; <5 ns common mode <5% Norm...

[Page 19] Minuteman PRO-E

18 English (These items may require optional software or hardware) Function Factory Default Description User Choices Set inverter output voltage Shut- down Type Set audible alarm state Enable/ Disable auto restart Battery life in days Battery install...

[Page 20] Minuteman PRO-E

19 English Para Systems Inc. (Para Systems) warrants this equipment, when properly applied and operated within specified conditions, against faulty materials or workmanship for a period of three years from the date of purchase. For equip- ment sites...

[Page 21] Minuteman PRO-E

20 English EXCEPT AS PROVIDED ABOVE, IN NO EVENT WILL PARA SYSTEMS BE LIABLE FOR DIRECT, INDIRECT, SPECIAL, INCIDENTAL, OR CONSEQUEN- TIAL DAMAGES ARISING OUT OF THE USE OF THIS PRODUCT, EVEN IF ADVISED OF THE POSSIBILITY OF SUCH DAMAGE. Specificall...

[Page 22] Minuteman PRO-E

21 DECLARATION OF CONFORMITY Application of Council Directive(s): 89/336/EEC, 73/23/EEC Standard(s) to which Conformity is declared: EN50091-1-1, EN50091-2 Manufacturer’s Name: Para Systems, Inc. (MINUTEMAN UPS) Manufacturer’s Address: 1455 LeMa...

[Page 23] Minuteman PRO-E

22 English Notes: ...

[Page 24] Minuteman PRO-E

Para Systems, Inc. 1455 Lemay Dr. Carrollton, TX 75007 Phone: 1-972-446-7363 Fax: 1-972-446-9011 Internet: minutemanups.com UPS Sizing: sizemyups.com PN - 34000226 Rev. 0 ...