Waeco CF-80 Instruction Manual

[Page 1] Waeco CF-80

M_70501 CF-80 AC CF-110 AC CF-80, CF-110 AAUUSS Compressor Cooler Instruction Manual CF80-110_M_70501 23/5/07 10:49 AM Page 1 ...

[Page 2] Waeco CF-80

3 CoolFreeze Please read this operating manual carefully before starting the device. Keep it in a safe place for future reference. If the device is handed over to another person, this operating manual must be handed over along with the device. Conte...

[Page 3] Waeco CF-80

4 CoolFreeze 2 ° 1 4 3 ON OFF SET POWER UP + DOWN – ERROR ° 1 3 4 5 6 72 100-240V~AC FUSE 1 2 12/24V DC 34 1 2 3 CF80-110_M_70501 23/5/07 10:49 AM Page 4 ...

[Page 4] Waeco CF-80

5 CoolFreeze O N O F F T U R B O P O W E R E R R O R ∞ C T E M P + T E M P ñ O N O F F T U R B O P O W E R E R R O R ∞ C T E M P + TE M P ñ 1 2 4 5 CF80-110_M_70501 23/5/07 10:49 AM Page 5 ...

[Page 5] Waeco CF-80

6 CoolFreeze 1 2 6 8 O N O F F T U R B O P O W E R E R R O R  C T E M P + T E M P ñ 7 CF80-110_M_70501 23/5/07 10:49 AM Page 6 ...

[Page 6] Waeco CF-80

7 CoolFreezeNotes on using the manual 1. Notes on using the manual The following symbols are used in this operating manual: Caution! Safety instruction: Failure to observe this instruction can cause personal injury or damage the device. Caution! Safe...

[Page 7] Waeco CF-80

8 CoolFreeze Safety Instructions • Only connect the device as follows: – using the cable supplied (Fig. 1 2, page 4) to a 12- V or 24- V battery – or with the AC cable supplied (Fig. 1 3, page 4) to the 100–240V AC mains. • If the connect...

[Page 8] Waeco CF-80

9 CoolFreeze Intended use • Warning! • Do not place any electrical devices inside the cooler. • Set up the device in a dry location where it is protected against splashing water. • Protect the device and the cable against rain and moisture. �...

[Page 9] Waeco CF-80

10 CoolFreeze Function description 5. Function description The cooler can chill products, keep them cool as well as freeze them. A low maintenance, CFC-free refrigerant circuit with compressor provides the cooling. The extra strong CFC-free insulati...

[Page 10] Waeco CF-80

11 CoolFreeze Operation 5.2 Connections Connection sockets (Fig. 3 , page 4) Item Description 1 Connection socket AC voltage supply 2 Fuse holder 3 Connection socket DC voltage supply 4 Emergency switch 6. Operation 6.1 Before initial use Note: Befo...

[Page 11] Waeco CF-80

12 CoolFreeze Operation 6.2 Energy saving tips • Choose a well ventilated installation location which is protected from direct sunlight. • Allow hot food to cool down first before you place it into the device. • Do not open the cooler more of...

[Page 12] Waeco CF-80

13 CoolFreeze Operation Caution – Danger of damaging the device! Make sure that the polarity is correct. ➤ Before starting up the device for the first time, check whether the operating voltage and the battery voltage correspond (see type plate...

[Page 13] Waeco CF-80

14 CoolFreeze Operation 6.4 Using the battery monitor. The device is equipped with a multi-level battery monitor that protects your vehicle battery against excessive discharging when the device is connected to the on-board 12/24 V supply. If the coo...

[Page 14] Waeco CF-80

15 CoolFreeze Operation 6.5 Using the cooler Caution – Danger of overheating! Ensure at all times that there is sufficient ventilation so that the heat generated during operation can dissipate. Ensure that the ventilation slots are not covered. M...

[Page 15] Waeco CF-80

16 CoolFreeze Operation 6.6 Setting the temperature ➤ Press the “SET” button (Fig. 2 4, page 4) once. ➤ Use the “UP +” (Fig. 2 6, page 4) and “DOWN -” (Fig. 2 7, page 4) buttons to select the cooling temperature. ✔ The cooling temp...

[Page 16] Waeco CF-80

17 CoolFreeze Operation 6.10 Replacing the device fuse Caution – Danger of electrocution! Disconnect the connection cable before you replace the device fuse. ➤ Pull off the connection cable. 6.11 Replacing the light bulb ➤ Press the switch pi...

[Page 17] Waeco CF-80

18 CoolFreeze Troubleshooting Possible cause Battery voltage is too low. No voltage present in the AC voltage socket. The device fuse is defective. The integrated mains adapter is defective. Defective compressor. Battery voltage is too low. The appli...

[Page 18] Waeco CF-80

10. Disposal ➤ Place the packaging material in the appropriate recycling waste bins wherever possible. If you wish to finally dispose of the device, ask your local recycling centre or specialist dealer for details about how to do this in accorda...

[Page 19] Waeco CF-80

20 CoolFreeze AAUUSS NNZZ Internet http://www.waeco.com.au http://www.waeco.co.nz WAECO Western Australia 9 Hod Way Malaga WA 6090 phone: 1800 21 21 21 fax: (08)9209 3577 WAECO New Zealand Unit 15, 180 Montgomerie Road Airport Oaks, Auckland 1701 ...