YAMAHA FZ8-S Owner's Manual

[Page 1] Yamaha FZ8-S

DIC183 FZ8-S FZ8-SA OWNER’S MANUAL Read this manual carefully before operating this vehicle. 42P-28199-E0 ...

[Page 2] Yamaha FZ8-S

EAU26945 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. DECLARATION of CONFORMITY General manager of quality assurance div. 1 Version up the norm of EN60950 to EN60950-1 To change c...

[Page 3] Yamaha FZ8-S

INTRODUCTION EAU10102 Welcome to the Yamaha world of motorcycling! As the owner of the FZ8-S/FZ8-SA, you are benefiting from Yamaha’s vast experience and newest technology regarding the design and manufacture of high-quality products, which have ea...

[Page 4] Yamaha FZ8-S

IMPORTANT MANUAL INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messa...

[Page 5] Yamaha FZ8-S

IMPORTANT MANUAL INFORMATION EAU10200 FZ8-S/FZ8-SA OWNER’S MANUAL ©2010 by Yamaha Motor Co., Ltd. 1st edition, March 2010 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Co., Ltd. is expres...

[Page 6] Yamaha FZ8-S

TABLE OF CONTENTS SAFETY INFORMATION ..................1-1 DESCRIPTION ..................................2-1 Left view ..........................................2-1 Right view........................................2-2 Controls and instruments........

[Page 7] Yamaha FZ8-S

TABLE OF CONTENTS Battery ..........................................6-31 Replacing the fuses ......................6-32 Replacing a headlight bulb ...........6-35 Replacing the tail/brake light bulb ...........................................6-36 R...

[Page 8] Yamaha FZ8-S

1-1 1 SAFETY INFORMATION EAU10286 Be a Responsible Owner As the vehicle’s owner, you are respon- sible for the safe and proper operation of your motorcycle. Motorcycles are single-track vehicles. Their safe use and operation are de- pendent upon t...

[Page 9] Yamaha FZ8-S

SAFETY INFORMATION 1-2 1 due to excessive speed or under- cornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warrant- ed by road and traffic conditions. • Always signal before turning or ...

[Page 10] Yamaha FZ8-S

SAFETY INFORMATION 1-3 1 ● Do not run engine in poorly venti- lated or partially enclosed areas such as barns, garages, or car- ports. ● Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows...

[Page 11] Yamaha FZ8-S

SAFETY INFORMATION 1-4 1 modifications not specifically recom- mended by Yamaha, even if sold and installed by a Yamaha dealer. Aftermarket Parts, Accessories, and Modifications While you may find aftermarket prod- ucts similar in design and quality ...

[Page 12] Yamaha FZ8-S

SAFETY INFORMATION 1-5 1 ● Check that the fuel cock (if equipped) is in the “OFF” position and that there are no fuel leaks. ● Point the front wheel straight ahead on the trailer or in the truck bed, and choke it in a rail to pre- vent moveme...

[Page 13] Yamaha FZ8-S

DESCRIPTION 2-1 2 EAU10410 Left view 1 2 5,643 1011 9 8 7 1. Air filter element (page 6-14) 2. Passenger seat lock (page 3-18) 3. Main fuse (page 6-32) 4. Fuel injection system fuse (page 6-32) 5. Storage compartment (page 3-20) 6. Owner’s tool kit...

[Page 14] Yamaha FZ8-S

DESCRIPTION 2-2 2 EAU10420 Right view 798 23 5461 1. Luggage strap holder (page 3-22) 2. Fuse box (page 6-32) 3. Battery (page 6-31) 4. Rear brake fluid reservoir (page 6-24) 5. Coolant reservoir (page 6-13) 6. Engine oil filler cap (page 6-10) 7. En...

[Page 15] Yamaha FZ8-S

DESCRIPTION 2-3 2 EAU10430 Controls and instruments 123 567 84 1. Clutch lever (page 3-13) 2. Left handlebar switches (page 3-12) 3. Main switch/steering lock (page 3-2) 4. Multi-function meter unit (page 3-8) 5. Front brake fluid reservoir (page 6-2...

[Page 16] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-1 3 EAU10976 Immobilizer system This vehicle is equipped with an immo- bilizer system to help prevent theft by re-registering codes in the standard keys. This system consists of the fol- lowing: ● a code re-regis...

[Page 17] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-2 3 ● Keep other immobilizer system keys away from the main switch as they may cause signal inter- ference. EAU10472 Main switch/steering lock The main switch/steering lock controls the ignition and lighting syst...

[Page 18] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-3 3 EAU10683 LOCK The steering is locked, and all electrical systems are off. The key can be re- moved. To lock the steering 1. Turn the handlebars all the way to the left. 2. Push the key in from the “OFF” po- ...

[Page 19] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-4 3 EAU49391 Indicator lights and warning lights EAU11020 Turn signal indicator light “” This indicator light flashes when the turn signal switch is pushed to the left or right. EAU11060 Neutral indicator lig...

[Page 20] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-5 3 NOTICE ECA10021 Do not continue to operate the en- gine if it is overheating. TIP ● For radiator-fan-equipped vehi- cles, the radiator fan(s) automati- cally switch on or off according to the coolant temperatu...

[Page 21] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-6 3 Coolant temperature Display Conditions What to do Under 39 °C (Under 103 °F) Message “Lo” is displayed. OK. Go ahead with riding. 40–116 °C (104–242 °F) Temperature is displayed. OK. Go ahead with...

[Page 22] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-7 3 EAU11534 Engine trouble warning light “” This warning light comes on or flashes if a problem is detected in the electrical circuit monitoring the engine. If this oc- curs, have a Yamaha dealer check the sel...

[Page 23] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-8 3 EAU46764 Multi-function meter unit WARNING EWA12422 Be sure to stop the vehicle before making any setting changes to the multi-function meter unit. Changing settings while riding can distract the operator and i...

[Page 24] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-9 3 Clock The clock displays when the key is turned to “ON”. In addition, the clock can be displayed for 10 seconds by pushing the “SELECT” button when the main switch is in the “OFF”, “LOCK” or “...

[Page 25] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-10 3 The fuel meter indicates the amount of fuel in the fuel tank. The display seg- ments of the fuel meter disappear to- wards “E” (Empty) as the fuel level decreases. When the last segment on the left starts ...

[Page 26] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-11 3 TIP If the display indicates error code 52, this could be caused by transponder in- terference. If this error code appears, try the following. 1. Use the code re-registering key to start the engine. TIP Make su...

[Page 27] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-12 3 EAU12348 Handlebar switches Left Right EAU12350 Pass switch “” Press this switch to flash the headlight. EAU12400 Dimmer switch “ / ” Set this switch to “” for the high beam and to “” for the...

[Page 28] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-13 3 EAU12733 Hazard switch “” With the key in the “ON” or “” posi- tion, use this switch to turn on the haz- ard lights (simultaneous flashing of all turn signal lights). The hazard lights are used in ...

[Page 29] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-14 3 EAU26823 Brake lever The brake lever is located at the right handlebar grip. To apply the front brake, pull the lever toward the handle- bar grip. The brake lever is equipped with a brake lever position adjust...

[Page 30] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-15 3 even slightly applied, a vibration can be felt at the lever and pedal, but these do not indicate a mal- function. ● When the ABS is activated, the brakes are operated in the usual way. A pulsating action may ...

[Page 31] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-16 3 TIP The fuel tank cap cannot be closed un- less the key is in the lock. In addition, the key cannot be removed if the cap is not properly closed and locked. WARNING EWA11091 Make sure that the fuel tank cap is ...

[Page 32] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-17 3 ately. If gasoline spills on your skin, wash with soap and water. If gaso- line spills on your clothing, change your clothes. EAU49740 NOTICE ECA11400 Use only unleaded gasoline. The use of leaded gasoline will...

[Page 33] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-18 3 EAU13433 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. WARNING EWA10862 The exhaust system is hot after op- eration. To prevent a fire hazard or burns: ● Do not...

[Page 34] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-19 3 To install the passenger seat 1. Insert the projections on the front of the passenger seat into the seat holders as shown, and then push the rear of the seat down to lock it in place. 2. Remove the key. Rider s...

[Page 35] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-20 3 EAU49630 Storage compartment This storage compartment is designed to hold an optional genuine Yamaha CYCLELOK. (Other locks may not fit.) To store a CYCLELOK, move the own- er’s tool kit in the storage compa...

[Page 36] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-21 3 EAU39671 Rear view mirrors The rear view mirrors of this vehicle can be folded forward or backward for park- ing in narrow spaces. Fold the mirrors back to their original position before riding. WARNING EWA143...

[Page 37] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-22 3 ● Do not tamper with or attempt to open the cylinder assembly. ● Do not subject the shock ab- sorber assembly to an open flame or other high heat source. This may cause the unit to ex- plode due to excessiv...

[Page 38] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-23 3 below and have a Yamaha dealer re- pair it if it does not function proper- ly. EAU44892 Ignition circuit cut-off system The ignition circuit cut-off system (com- prising the sidestand switch, clutch switch and...

[Page 39] Yamaha FZ8-S

INSTRUMENT AND CONTROL FUNCTIONS 3-24 3 With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is set to “ 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch....

[Page 40] Yamaha FZ8-S

FOR YOUR SAFETY – PRE-OPERATION CHECKS 4-1 4 EAU15596 Inspect your vehicle each time you use it to make sure the vehicle is in safe operating condition. Always follow the inspection and maintenance procedures and schedules described in the Owner’...

[Page 41] Yamaha FZ8-S

FOR YOUR SAFETY – PRE-OPERATION CHECKS 4-2 4 Rear brake • Check operation. • If soft or spongy, have Yamaha dealer bleed hydraulic system. • Check brake pads for wear. • Replace if necessary. • Check fluid level in reservoir. • If neces...

[Page 42] Yamaha FZ8-S

FOR YOUR SAFETY – PRE-OPERATION CHECKS 4-3 4 Chassis fasteners • Make sure that all nuts, bolts and screws are properly tightened. • Tighten if necessary. — Instruments, lights, signals and switches • Check operation. • Correct if necess...

[Page 43] Yamaha FZ8-S

OPERATION AND IMPORTANT RIDING POINTS 5-1 5 EAU15951 Read the Owner’s Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. WARNING EWA10271 Failure to familiarize yo...

[Page 44] Yamaha FZ8-S

OPERATION AND IMPORTANT RIDING POINTS 5-2 5 NOTICE ECA11833 If a warning or indicator light does not come on initially when the key is turned to “ON”, or if a warning or in- dicator light remains on, see page 3-4 for the corresponding warning and...

[Page 45] Yamaha FZ8-S

OPERATION AND IMPORTANT RIDING POINTS 5-3 5 EAU16810 Tips for reducing fuel con- sumption Fuel consumption depends largely on your riding style. Consider the following tips to reduce fuel consumption: ● Shift up swiftly, and avoid high en- gine sp...

[Page 46] Yamaha FZ8-S

OPERATION AND IMPORTANT RIDING POINTS 5-4 5 EAU17213 Parking When parking, stop the engine, and then remove the key from the main switch. WARNING EWA10311 ● Since the engine and exhaust system can become very hot, park in a place where pedestri- a...

[Page 47] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-1 6 EAU17242 Periodic inspection, adjustment, and lu- brication will keep your vehicle in the safest and most efficient condition pos- sible. Safety is an obligation of the vehi- cle owner/operator. The most impo...

[Page 48] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-2 6 EAU46861 TIP ● The annual checks must be performed every year, except if a kilometer-based maintenance, or for the UK, a mileage-based maintenance, is performed instead. ● From 50000 km (30000 mi), repeat...

[Page 49] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-3 6 EAU1770C General maintenance and lubrication chart NO. ITEM CHECK OR MAINTENANCE JOB ODOMETER READING ANNUAL CHECK 1000 km (600 mi) 10000 km (6000 mi) 20000 km (12000 mi) 30000 km (18000 mi) 40000 km (...

[Page 50] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-4 6 10 Drive chain • Check chain slack, alignment and condition. • Adjust and lubricate chain with a special O-ring chain lubricant thoroughly. Every 1000 km (600 mi) and after washing the motorcycle, ridi...

[Page 51] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-5 6 21 * Rear suspension re- lay arm and con- necting arm pivoting points • Check operation. √√√√ 22 Engine oil • Change. • Check oil level and vehicle for oil leakage. √√√√√√ 23 Engin...

[Page 52] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-6 6 EAU18680 TIP ● Air filter • This model’s air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with com- pressed air to avoid damaging it. • The air filter eleme...

[Page 53] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-7 6 EAU18722 Removing and installing the cowling and panels The cowling and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the...

[Page 54] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-8 6 EAU49810 Panels A and B To remove one of the panels Remove the quick fastener and the bolts, and then pull the panel off as shown. To install the panel Place the panel in the original position, and then insta...

[Page 55] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-9 6 EAU19652 Checking the spark plugs The spark plugs are important engine components, which should be checked periodically, preferably by a Yamaha dealer. Since heat and deposits will cause any spark plug to sl...

[Page 56] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-10 6 EAU49791 Engine oil and oil filter car- tridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter car- tridge replaced at the intervals speci- f...

[Page 57] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-11 6 TIP Skip steps 6–8 if the oil filter cartridge is not being replaced. 6. Remove the oil filter cartridge with an oil filter wrench. FZ8-S FZ8-SA TIP An oil filter wrench is available at a Yamaha dealer. 7....

[Page 58] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-12 6 FZ8-S FZ8-SA 9. Install the engine oil drain bolt and its new gasket, and then tighten the bolt to the specified torque. 10. Refill with the specified amount of the recommended engine oil, and then install a...

[Page 59] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-13 6 NOTICE ECA10401 If the oil level warning light flickers or remains on even if the oil level is correct, immediately turn the engine off and have a Yamaha dealer check the vehicle. 12. Turn the engine off, wa...

[Page 60] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-14 6 If water has been used instead of coolant, replace it with cool- ant as soon as possible, other- wise the cooling system will not be protected against frost and corrosion. If water has been added to the cool...

[Page 61] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-15 6 5. Pull the bottom of the fuel tank cowling outward on both sides, then remove the cowling by mov- ing it forward, and then lifting it up. 6. Remove the fuel tank bolt on both sides. 7. Lift the front of the...

[Page 62] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-16 6 9. Pull the air filter element out. 10. Insert a new air filter element into the air filter case. NOTICE: Make sure that the air filter element is properly seated in the air filter case. The engine should ne...

[Page 63] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-17 6 15. Install the side cowling bolt on both sides. 16. Install the panels. 17. Install the rider seat. EAU34301 Adjusting the engine idling speed The engine idling speed must be checked and, if necessary, ad...

[Page 64] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-18 6 EAU21383 Checking the throttle cable free play The throttle cable free play should mea- sure 3.0–5.0 mm (0.12–0.20 in) at the inner edge of the throttle grip. Periodi- cally check the throttle cable fr...

[Page 65] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-19 6 WARNING EWA10511 Never overload your vehicle. Opera- tion of an overloaded vehicle could cause an accident. Tire inspection The tires must be checked before each ride. If the center tread depth reaches the s...

[Page 66] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-20 6 Tire information This motorcycle is equipped with cast wheels and tubeless tires with valves. WARNING EWA10481 ● The front and rear tires should be of the same make and de- sign, otherwise the handling cha...

[Page 67] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-21 6 EAU21961 Cast wheels To maximize the performance, durabil- ity, and safe operation of your vehicle, note the following points regarding the specified wheels. ● The wheel rims should be checked for cracks,...

[Page 68] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-22 6 EAU37913 Checking the brake lever free play There should be no free play at the brake lever end. If there is free play, have a Yamaha dealer inspect the brake system. WARNING EWA14211 A soft or spongy feel...

[Page 69] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-23 6 EAU36503 Brake light switches (FZ8-SA) The brake light, which is activated by the brake pedal and brake lever, should come on just before braking takes ef- fect. If necessary, have a Yamaha deal- er adjust t...

[Page 70] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-24 6 EAU49860 Checking the brake fluid level Front brake Rear brake FZ8-S FZ8-SA Insufficient brake fluid may allow air to enter the brake system, possibly caus- ing it to become ineffective. Before riding, chec...

[Page 71] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-25 6 ● Brake fluid may deteriorate paint- ed surfaces or plastic parts. Al- ways clean up spilled fluid immediately. ● As the brake pads wear, it is nor- mal for the brake fluid level to grad- ually go down. ...

[Page 72] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-26 6 4. If the drive chain slack is incorrect, adjust it as follows. EAU34316 To adjust the drive chain slack 1. Loosen the axle nut and the lock- nut on each side of the swingarm. 2. To tighten the drive chain, ...

[Page 73] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-27 6 EAU23025 Cleaning and lubricating the drive chain The drive chain must be cleaned and lubricated at the intervals specified in the periodic maintenance and lubrica- tion chart, otherwise it will quickly we...

[Page 74] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-28 6 EAU23113 Checking and lubricating the throttle grip and cable The operation of the throttle grip should be checked before each ride. In addi- tion, the cable should be lubricated by a Yamaha dealer at the ...

[Page 75] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-29 6 EAU23142 Checking and lubricating the brake and clutch levers Brake lever Clutch lever The operation of the brake and clutch levers should be checked before each ride, and the lever pivots should be lu- br...

[Page 76] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-30 6 EAU23272 Checking the front fork The condition and operation of the front fork must be checked as follows at the intervals specified in the periodic main- tenance and lubrication chart. To check the conditi...

[Page 77] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-31 6 EAU23291 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrica- tion chart. If there is play in the wheel hub or if...

[Page 78] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-32 6 NOTICE ECA16521 To charge a VRLA (Valve Regulated Lead Acid) battery, a special (con- stant-voltage) battery charger is re- quired. Using a conventional battery charger will damage the battery. To store the ...

[Page 79] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-33 6 FZ8-S FZ8-SA FZ8-SA 1. Fuse box 2. Ignition fuse 3. Signaling system fuse 4. Taillight fuse 5. Backup fuse (for clock and immobilizer sys- tem) 6. Right radiator fan fuse 7. Left radiator fan fuse 8. Headlig...

[Page 80] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-34 6 FZ8-SA If a fuse is blown, replace it as follows. 1. Turn the key to “OFF” and turn off the electrical circuit in question. 2. Remove the blown fuse, and then install a new fuse of the specified amperage...

[Page 81] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-35 6 EAU23932 Replacing a headlight bulb This model is equipped with quartz bulb headlights. If a headlight bulb burns out, replace it as follows. NOTICE ECA10650 Take care not to damage the follow- ing parts: �...

[Page 82] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-36 6 EAU24114 Replacing the tail/brake light bulb 1. Remove the passenger seat. (See page 3-18.) 2. Remove the socket (together with the bulb) by turning it counter- clockwise. 3. Remove the burnt-out bulb by p...

[Page 83] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-37 6 EAU24313 Replacing the license plate light bulb 1. Remove the license plate light unit by removing the screws. 2. Remove the license plate light bulb socket (together with the bulb) by pulling it out. 3. R...

[Page 84] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-38 6 4. Insert a new bulb into the socket. 5. Install the auxiliary light bulb sock- et (together with the bulb) by push- ing it in. 6. Install the panel. EAU24350 Supporting the motorcycle Since this model is n...

[Page 85] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-39 6 EAU44790 Front wheel (FZ8-S) WARNING EWA14840 For the ABS model, have a Yamaha dealer remove and install the wheel. EAU39393 To remove the front wheel WARNING EWA10821 To avoid injury, securely support the v...

[Page 86] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-40 6 TIP Make sure that there is enough space between the brake pads before install- ing the brake calipers onto the brake discs. 5. Install the brake hose holders by installing the bolt and nut. 6. Tighten the w...

[Page 87] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-41 6 TIP ● If the drive chain is difficult to re- move, remove the wheel axle first, and then lift the wheel upward enough to remove the drive chain from the rear sprocket. ● The drive chain cannot be disas- ...

[Page 88] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-42 6 EAU25871 Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur dur- ing operation. Any problem in the fuel, compression, or ignition s...

[Page 89] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-43 6 EAU42361 Troubleshooting charts Starting problems or poor engine performance Check the fuel level in the fuel tank. 1. Fuel There is enough fuel. There is no fuel. Check the compression. Supply fuel. The en...

[Page 90] Yamaha FZ8-S

PERIODIC MAINTENANCE AND ADJUSTMENT 6-44 6 Engine overheating WARNING EWA10400 ● Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be...

[Page 91] Yamaha FZ8-S

MOTORCYCLE CARE AND STORAGE 7-1 7 EAU37833 Matte color caution NOTICE ECA15192 Some models are equipped with matte colored finished parts. Be sure to consult a Yamaha dealer for advice on what products to use be- fore cleaning the vehicle. Using a b...

[Page 92] Yamaha FZ8-S

MOTORCYCLE CARE AND STORAGE 7-2 7 off any detergent residue using plenty of water, as it is harmful to plastic parts. ● Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact wit...

[Page 93] Yamaha FZ8-S

MOTORCYCLE CARE AND STORAGE 7-3 7 4. To prevent corrosion, it is recom- mended to apply a corrosion pro- tection spray on all metal, including chrome- and nickel-plat- ed, surfaces. 5. Use spray oil as a universal clean- er to remove any remaining di...

[Page 94] Yamaha FZ8-S

MOTORCYCLE CARE AND STORAGE 7-4 7 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 3. Perform the following steps to pro- tect the cylinders, piston rings, etc. fro...

[Page 95] Yamaha FZ8-S

SPECIFICATIONS 8-1 8 Dimensions: Overall length: 2140 mm (84.3 in) Overall width: 770 mm (30.3 in) Overall height: 1225 mm (48.2 in) Seat height: 815 mm (32.1 in) Wheelbase: 1460 mm (57.5 in) Ground clearance: 140 mm (5.51 in) Minimum turning radius:...

[Page 96] Yamaha FZ8-S

SPECIFICATIONS 8-2 8 Gear ratio: 1st: 35/13 (2.692) 2nd: 33/16 (2.063) 3rd: 37/21 (1.762) 4th: 35/23 (1.522) 5th: 27/20 (1.350) 6th: 29/24 (1.208) Chassis: Frame type: Diamond Caster angle: 25.00 ° Trail: 109.0 mm (4.29 in) Front tire: Type: Tubeles...

[Page 97] Yamaha FZ8-S

SPECIFICATIONS 8-3 8 Charging system: AC magneto Battery: Model: YTZ10S Voltage, capacity: 12 V, 8.6 Ah Headlight: Bulb type: Halogen bulb Bulb voltage, wattage × quantity: Headlight: 12 V, 60 W/55 W × 1 Headlight: 12 V, 55 W × 1 Tail/brake light:...

[Page 98] Yamaha FZ8-S

CONSUMER INFORMATION 9-1 9 EAU48610 Identification numbers Record the vehicle identification num- ber and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the...

[Page 99] Yamaha FZ8-S

INDEX A ABS (for ABS models) .......................... 3-14 ABS warning light (for ABS models)....... 3-7 Air filter element, replacing ................... 6-14 Anti-theft alarm (optional) ..................... 3-11 Auxiliary light bulb, replacing ....

[Page 100] Yamaha FZ8-S

INDEX Tool kit .................................................... 6-1 Troubleshooting .................................... 6-42 Troubleshooting charts ......................... 6-43 Turn signal indicator light ........................ 3-4 Turn sign...