Download or browse on-line these Important Operating, Maintenance And Safety Instructions for Chevrolet station wagon 1970 Automobile.
This manual for Chevrolet station wagon 1970, given in the PDF format, is available for free online viewing and download without logging on. The guide contains 91 pages, and the size of the file at download is . The document type is Important Operating, Maintenance And Safety Instructions.
[Page 1] Chevrolet station wagon 1970
...
[Page 2] Chevrolet station wagon 1970
file:///C|/Documents%20and%20Settings/Tim/Desktop/carburetor-manual-welcome/index.htm[4/25/2009 11:42:20 AM] www.carburetor-manual.com Would you like some Free Manuals? http://carburetor-manual.com/free-shop-manual-club-t-13.html Also visit http://fr...
[Page 3] Chevrolet station wagon 1970
" \ '. ; ~ . ," . "",; '; .. GM '"W"!,E"" This is the General Motors mark of excellence that appears on all Chevrolet motor vehicles. We use it in the same spirit ...
[Page 4] Chevrolet station wagon 1970
IMPORTANT INFORMATION FOR THE CHEVROLET STATION WAGON OWNER This manual has been prepared to acquaint you with the operation and maintenance of your 1970 Chevrolet Station Wagon. We urge you to read it carefully and ...
[Page 5] Chevrolet station wagon 1970
Safety on the Road depends on ... 1. You, the Driver 2. The Condition of Your Vehicle 3. Traffic and Highway Conditions . . . BE SURE YOU UNDERSTAND ALL THREE I REMEMBER Proper operation, periodic maintenance and safety i...
[Page 6] Chevrolet station wagon 1970
INCLEMENT WEATHER Proceed cautiously in inclement weather, until you are sure it is safe to drive faster. Be prepared for sudden crosswinds when crossing bridges or viaducts. . Remember that some wet pavement is as treachero...
[Page 7] Chevrolet station wagon 1970
A WORD FROM CHEVROLET ••• This Owners Manual contains important information regarding the operation and maintenance of your Chevrolet station wagon. In order to obtain maximum enjoyment and usage from your car, we suggest that you ...
[Page 8] Chevrolet station wagon 1970
YOUR CHEVROLET'S FIRST FEW HUNDRED MILES OF DRIVING Sound design and precision manufac- turing methods will permit you to operate your new Chevrolet from its very first mile without adhering to a formal "brea...
[Page 9] Chevrolet station wagon 1970
Driving For Economy Proper maintenance and wise opera- tion will combine to help you achieve maximum fuel economy with your Chevrolet. Your Authorized Chevrolet Dealer can properly tune and main- CAUTION: Avoid Inhaling ...
[Page 10] Chevrolet station wagon 1970
----OPERATING INSTRUCTIONS Anti-Theft Steering Column Lock The anti-theft lock, located on the right side of the steering column, has five positions. Starting from the full counterclockwise position (the posi- tion nearest ...
[Page 11] Chevrolet station wagon 1970
Starting Engine CAUTION: When starting the engine with the car parked, always have the· brake applied-use the foot brake on automatic transmission cars and the parking brake on manual transmission cars. NOTE: To prolong b...
[Page 12] Chevrolet station wagon 1970
.--- .. . Driving with the Chevrolet Manual Transmissions The 3-speed manual transmission shift positions follow the standard pattern shown. Depress the clutch pedal fully before shifting to a different gear, then releas...
[Page 13] Chevrolet station wagon 1970
P-PARK R-REVERSE N-NEUTRAL D-DRIVE L-LOW 10 POWERGLIDE Use only when car is stopped. For backing car-from stop. For standing (Brakes Applied). For forward driving. Depress accelerator to floor for extra acceleration at ...
[Page 14] Chevrolet station wagon 1970
safety switch designed to permit start- ing the engine only when the trans- mission selector is in the "Park" or "N eutral" position. For additional engine braking effect, as sometimes needed in mount...
[Page 15] Chevrolet station wagon 1970
CAUTION: Attachment should NOT be made to bumpeis or bumper <brackets tor towing. When vehicle is towed in a manner that re- quires hoisting one ehd off the ground, this is to be done only with a sling-type attachment hooke...
[Page 16] Chevrolet station wagon 1970
action generates hydrogen gas which is explosive when mixed with air, never expose the battery to an open flame or electric spark. Also, avoid getting battery fluid, which is a sul- furic acid solution, on skin, on ...
[Page 17] Chevrolet station wagon 1970
INSTRUMENTS The instruments, gauges and indicator lights conveniently grouped in the in- strument cluster are designed to tell you at a glance many important things about the performance of your car. The information . o...
[Page 18] Chevrolet station wagon 1970
Engine Temperature Indicator Light This indicator light is provided in the instrument cluster to quickly warn of an overheated engine. With the ig- nition switch in the START position, _ the red (HOT) indicator will li...
[Page 19] Chevrolet station wagon 1970
Optional Instruments and Gauges -116" W.B. -:;' \~"/ -40 $ +40 AMPS Tachometer and Oil Pressure Light The optional Tachometer indicates the speed of the engine in revolutions per minute. The yellow area ...
[Page 20] Chevrolet station wagon 1970
Headlight Beam Indicator Light The headlights of your Chevrolet have high and low beams to provide you with proper night-time visibility during all driving conditions. The "low" beams are used during most city ...
[Page 21] Chevrolet station wagon 1970
CONTROLS ASTRO VENTIlATION LEFT OUTlET HEATER CONTROLS (OPTIONAL AIR CONDITIONING CONTROLS) 18 OPTIONAL CLOCK GLOVE BOX LOCK ...
[Page 22] Chevrolet station wagon 1970
MAINTAINING SAFETY AND DEPENDABILITY li sted be low are a number of vehicle fe atures that should be periodically checked to help mainta in continued sa fe and depe ndable vehicle operation . Some wi ll require physical c...
[Page 23] Chevrolet station wagon 1970
application. Parking brake adjustment should be checked whenever brake linings are checked, and front wheel bearings should be lubricated whenever brake drums are removed Owners should periodically check parking brake fu...
[Page 24] Chevrolet station wagon 1970
light operation while you activate the brake pedal and switches involved. Have any malfunctions cor- rected for your benefit and for the benefit of other drivers too. Headlamp aim should also be checked periodically. F...
[Page 25] Chevrolet station wagon 1970
vehicle use. Drivers should check defroster perform- ance by turning controls to "de- ice" and noting whether a good supply of air is directed against the windshield. Cause of weak or mis-directed air flows should be...
[Page 26] Chevrolet station wagon 1970
CAUTION: It is the owner's responsibility to check all lamps, signaling systems and warning lights frequently to be sure they are working properly. Headlamp aim should be checked periodically. It is important that...
[Page 27] Chevrolet station wagon 1970
Four-Way Hazard Warning Flasher In the event your car is disabled or you stop for any reason on the high- way, the four-way hazard warning flasher system on your vehicle, front and rear signal lamps, should be used t...
[Page 28] Chevrolet station wagon 1970
Good Driving Practice: A good driver turns on his headlamps at early dusk, and during bad weather to help other drivers see his car from a distance, even though he himself may still be able to see the roadway adeq...
[Page 29] Chevrolet station wagon 1970
CAUTION: Driving through deep water may affect brake performance. Applying the brakes lightly will indicate whether they have been affected. To dry them quickly, lightly apply the brakes while maintaining a slow forward ...
[Page 30] Chevrolet station wagon 1970
CAUTION: Brake linings should be periodically inspected for wear by a qualified technician. The frequency of this inspection depends upon driving conditions such as traffic or terrain, and also the driving techniques of individual owne...
[Page 31] Chevrolet station wagon 1970
monitor will indicate the level of windshield washer solution in the washer jar. The lens on the instru- ment panel will glow red when the solution is low or green when the level is adequate whenever the wind- shie...
[Page 32] Chevrolet station wagon 1970
Heater Push the AIR-FAN (on 119.0" W.B. wagons, AIR on 116.0" W.B. wagons) lever to the right to "AIR" to allow outside air into the vehicle. Further movement of the lever operates the low, medium ...
[Page 33] Chevrolet station wagon 1970
GM Chevrolet Air Conditioning System To operate the GM Chevrolet Air Conditioning System: • Turn the AIR knob to control the blower speed as desired. • The TEMP knob may be regulated to provide the degree of coo...
[Page 34] Chevrolet station wagon 1970
Four Season Air Conditioning System Temperature (Lower Lever) The temperature lever allows a selection of air temperature from Cold at the far left to Hot at the far right. When the temperature lever is in the COLD p...
[Page 35] Chevrolet station wagon 1970
"BI-LEVEL" - Outside air is passed through the system and discharged from both the upper and lower out- lets. This position is recommended for sunny cooler weather where warm air is required on the feet with ...
[Page 36] Chevrolet station wagon 1970
Air Conditioning Comfortron System-119.0" W. B. Station Wagons Comfortron Air Conditioning adds the convenience of completely auto- matic control to the combined heating and cooling functions of the Four- Season syste...
[Page 37] Chevrolet station wagon 1970
resulting in moderate to high airflow for rapid cool down or heating. Blower speeds will decrease as the tempera- ture approaches the dial setting. Bi Level Operation On cool but sunny days the Comfor- tron system wil...
[Page 38] Chevrolet station wagon 1970
, lIi . j ~~~ ... __ v ____ - ___ .:..... 'L '!- • Chevrolet "All Transistor" Radios To operate the radios, the ignition switch must be in "ON " or "ACC " position. Push Button AM ...
[Page 39] Chevrolet station wagon 1970
left channel and the opposite speakers reproducing the right channel. Bal- ancing the speakers is not required as this adjustment has been made at the factory. Should it become necessary to make this adjustment, see ...
[Page 40] Chevrolet station wagon 1970
Seats Manually Operated Front Seats-Pull forward on the seat adjuster lever, located on the driver's side of the front seat , to unlock the seat and allow ad- justment to the front or rear . As the se at slides ...
[Page 41] Chevrolet station wagon 1970
Cruise-Master-119.0" w.e. The optional Cruise-Master provides fully automatic speed control for your comfort when traveling on turnpikes, expressways, or other non-congested highways. The system automatically disengages ...
[Page 42] Chevrolet station wagon 1970
Tilt Steering Wheel The optional tilt steering wheel can be tilted up above normal position to provide additional room for entrance and exit as well as selected driving positions below normal height. This permits indiv...
[Page 43] Chevrolet station wagon 1970
PRESS HERE TO RELEASE strong hip bone structure and not across the soft abdominal area. For retractor equipped belts, pull the re- tractor half of the belt to a solid stop to make sure that the belt webbing is co...
[Page 44] Chevrolet station wagon 1970
and released in the same manner as lap belts . A shoulder belt should not be uncomfortably tight. A fist's width between your chest and the belt should provide sufficient slack. This can be checked by inserting...
[Page 45] Chevrolet station wagon 1970
A front seat passenger wearing both shoulder and lap belts should lean into the shoulder belt, place hands and forearms on top of the instru- ment panel with elbows out to the side and head bent far forward. Front...
[Page 46] Chevrolet station wagon 1970
(Standard on 1967 and later model GM passenger vehicles). Otherwise the Carrier or Child Seat should be us ed on the re ar seat of the passenger vehicle. In using either Carrier or Child Seat, read and comply with ...
[Page 47] Chevrolet station wagon 1970
Rearview Mirrors Rearview mirrors are not intended for use while backing up, or for sur- veillance of conditions close to the rear of the car. It is suggested that the driver turn his head and look to the rear dur...
[Page 48] Chevrolet station wagon 1970
Ash Tray To remove, pull the ash tray out as far as it will go, depress the tab at the center rear and hold while pulling the tray out and down. Install by pushing the tray into place until it stops, de- press ...
[Page 49] Chevrolet station wagon 1970
CAUTION: Gasoline is flammable and explosive under certain conditions. Always stop the engine and do not smoke or allow open flames or sparks near the vehicle when refueling. If gasoline fumes are noticed while driving, the cause should...
[Page 50] Chevrolet station wagon 1970
CAUTION: Under some conditions, driving with the tailgate window open can permit exhaust fumes to enter the vehicle (see Exhaust Gas Warning, Page 6). If it is desired to drive with the tailgate open, the following precautions shoul...
[Page 51] Chevrolet station wagon 1970
ALL MODELS-SECOND SEAT in th~ "ON" or "ACC" position. Use the ignition key to operate the window from outside. The rear trim pad switch (three-seat station wagon only) op- erates .. only to lower t...
[Page 52] Chevrolet station wagon 1970
Dual Action Tailgate Operation Tailgate Latch • Lower tailgate window to full down position. • Raise up on tailgate latch at inside of tailgate. • Lower tailgate. Rear Door Latch • Lower tailgate window to full down...
[Page 53] Chevrolet station wagon 1970
Concealed Luggage Space 116.0" W.B. Sta. Wag . . To gain access to the concealed luggage space, raiseJid and prop with rod as shown in illustration. 46 Concealed Luggage Space- 119.0" W.B. Sta. Wag. • Use the ov...
[Page 54] Chevrolet station wagon 1970
Station Wagon Spare Tire and Jack Storage The spare tire and jacking equip- ment are stowed behind a removable panel in the right rear quarter panel. The panel is held in place by means of a toggle latch. After loosen...
[Page 55] Chevrolet station wagon 1970
CLEANING YOUR CHEVROLET STATION WAGON Exterior Appearance Your Chevrolet is finished with Gen- eral Motors "Magic-Mirror" acrylic lacquer. This is a finish of maximum beauty, which, in depth of color, gloss retenti...
[Page 56] Chevrolet station wagon 1970
LESS STEEL trim if necessary. Use special care with ALUMINUM trim. Never use auto or chrome polish, steam or any caustic soap to clean aluminum. A coating of wax, rubbed to a high polish, is recommended for all b...
[Page 57] Chevrolet station wagon 1970
GUARDIAN MAINTENANCE FOR OWNER PROTECTION THE IMPORTANCE OF PROTECTING YOUR INVESTMENT Your purchase of a 1970 Chevrolet Station Wagon was an important de- cision-one that represented a sizable investment. Unquestionably, ...
[Page 58] Chevrolet station wagon 1970
GUARDIAN MAINTENANCE SERVICE The quality of maintenance . your new car receives is as important as the regularity with which it is serv- iced. The "Guardian Maintenance Service" program has been developed by C...
[Page 59] Chevrolet station wagon 1970
Interval Every 6,000 miles or4 months, which- ever occurs first OWNER PROTECTION MAINTENANCE SCHEDULE Service To Be Performed • Change engine oii (normal passenger car service"). Not to exceed 6,000 miies. • Lubricate...
[Page 60] Chevrolet station wagon 1970
Interval First 12,000 miles Every 12 months or 12,000 miles Every 24,000 miles OWNER PROTECTION MAINTENANCE SCHEDULE Service To Be Performed • Inspect air cleaner element. If satisfactory, rotate 180 0 from original positio...
[Page 61] Chevrolet station wagon 1970
OWNER SAFETY CHECKS Take a few mi!mtes, periodically, to check the items listed below for proper operation. See "Maintaining Safety and Dependability" section for instructions on the recommended method of checki...
[Page 62] Chevrolet station wagon 1970
MAINTENANCE AND LUBRICATION Fuel Requirements Your Chevrolet is designed to oper- ate efficiently on "Regular" or "Pre- mium" grade fuels commonly sold in the United States and Canada, de- pending on th...
[Page 63] Chevrolet station wagon 1970
Engine Oil Recommendations Use only engine oil which meets GM 6041-M standard. High quality oils which are intended for service MS and pass car makers' tests are of this quality. The oil change interval (see sec...
[Page 64] Chevrolet station wagon 1970
as the last step in a fuel stop. This will allow the oil accumulation in the en- gine to drain back in the crankcase. To check the level, remove the oil gauge rod (dip stick), wipe it clean and reinsert it firm...
[Page 65] Chevrolet station wagon 1970
provide additional protection against freezing at temperatures lower than -20°F ., (-32°F. in Canada) a suffi- cient amount of an ethylene glycol base coolant meeting GM Specification 1899-M should be used. NOTE: Alcoh...
[Page 66] Chevrolet station wagon 1970
Tires The factory installed tires on your car are selected to provide the best all around tire performance for all normal operation. When inflated as recommended in the tire inflation placard affixed to the left doo...
[Page 67] Chevrolet station wagon 1970
CHEVROLET STATION WAGON TIRE USAGE Engine and Body Style Standard All Station Wagon H-78 x 15 or 119.0" WB. H-78 x 150 All Station Wagon G-78 x 14 or (116.0" WB.) G-78 x 140 All Standard and Optional Tires are Load...
[Page 68] Chevrolet station wagon 1970
D PART NO. TIRE SIZES & PLY RATING TIRE PRESSURES STANDARD COOL UP TO VEHICLE } FRONT D LOAD LIMIT REAR D OPTIONAL 1 TO 5 PASS . ] JRONT D ( LBS .) REAR D HOT D D D D VEHICLE CAPACITY BENCH BUCKET SEAT S E...
[Page 69] Chevrolet station wagon 1970
Tire Rotation To equalize wear it is recommended that the tires be rotated every 6,000 miles. Upon rotation, tire pressure must be adjusted (front and rear) in accordance with the recommendations in the tire inflation...
[Page 70] Chevrolet station wagon 1970
RECOMMENDED SCHEDULE FOR PERIODIC MAINTENANCE AND LUBRICATION The time or mileage intervals on the following pages are intended as a guide for establishing regular maintenance and lubrication periods for your Chevrolet. ...
[Page 71] Chevrolet station wagon 1970
(PCV) are important to control hy- dro-carbon and CO emissions within government legislated levels. These adjustments and an operational check of the PCV valve should be made at the first oil change (4 months or 6,000...
[Page 72] Chevrolet station wagon 1970
essary. If satisfactory, rotate element 180 0 from originally installed position. Replace element at 24,000 miles. Ele- ment must not be washed, oiled, tapped or cleaned with an air hose. Crankcase Ventilation Filter (loca...
[Page 73] Chevrolet station wagon 1970
Transmission at Operating Tempera- ture - Check the fluid level at each engine oil change period. For an ac- curate fluid level check, drive the car several miles, making frequent starts and stops, to bring the transm...
[Page 74] Chevrolet station wagon 1970
ON THE FOLLOWING THREE PAGES ... SOME IMPORTANT FACTS YOU SHOULD KNOW ABOUT AIR POLLUTION CONTROL SYSTEMS BACKGROUND INFORMATION: During the combus- tion process in an automot i ve engine, certain hydrocar- bons in the fue...
[Page 75] Chevrolet station wagon 1970
What you should know about Air Pollution Control ~ ' _ f ll lHRAa -+ , 1 1.0 . IlIiA Sl:I lI_+ ,., ~ COM N5l1. U "'UI( .tv *Positive Crankcase Ventilation (PCV) All General Motors vehicles are equipped with P...
[Page 76] Chevrolet station wagon 1970
'y stems on your Chevrolet, and the service required PISTON EX H AUST STROK[ AfTER COMIUSTlI)N * A ir Injector Reactor (AIR) KEY TO UR, SYSTE M CJ I. 'WGAII .. .. :!.=:~ ~ ltUllO Ulum f:'~'::"NQ Th...
[Page 77] Chevrolet station wagon 1970
Evaporation Control System (Required only in California) General Motors vehicles sold in California are equipped with an Evaporat ion Con tro l System. This system is desi gned to m in i- mize the escape of fuel vapors to the ...
[Page 78] Chevrolet station wagon 1970
Every 24,000 miles-the transmission sump filter should be replaced., Transmission Shift and Backdrive Linkage (Manual and Automatic) - Every 6,000 miles or 4 months lubri- cate shift linkage and on manual transmission fl...
[Page 79] Chevrolet station wagon 1970
is required for the life of the steering gear. Every 36 ,000 miles, the gear should be inspect ed for seal leakage (actual solid grease--,-not just oily film). If a seal is replaced or the gear is over- hauled, the...
[Page 80] Chevrolet station wagon 1970
----------------~railer Hauling Since passenger cars are designed and intended to be used primarily as passenger conveyances, towing a trail- er may affect handling, durability and economy. Maximum satisfaction and safety ...
[Page 81] Chevrolet station wagon 1970
MINOR TROUBLE SHOOTING GUIDE IMPORTANT: For maximum performance and economy, keep your GM car I I I I ali GM. Specify General Motors parts identified by one of these trademarks. l!MQ. G 70 • ...
[Page 82] Chevrolet station wagon 1970
The chart on the previous page, and the information on the pages which follow, contains information designed to aid the average driver to discover, and possibly correct, conditions resulting in minor mechanical difficulties in ...
[Page 83] Chevrolet station wagon 1970
IE) If the car will start but stalls when hot or has a rough idle, . you can suspect a faulty IDLE ADJUSTMENT, a malfunctioning AUTOMATIC CHOKE or an extremely dirty and blocked AIR CLEANER ELEMENT. Clean polyureth...
[Page 84] Chevrolet station wagon 1970
a bobby pin) between the rubber cup at the end of the spark plug wire and the tubular metal con- nector inside of it. If the spark plug wire is wet or oily, wipe it dry. Wrap a dry handkerchief or facial tissu...
[Page 85] Chevrolet station wagon 1970
SPECIFICATIONS VEHICLE IDENTIFICATION NUMBER Car-Stamped on vehicle identification number plate attached to left top of instrument panel. Body-Stamped on plate attached to upper right corner of cowl panel. Engine-Stamped ...
[Page 86] Chevrolet station wagon 1970
ENGINE SPECIFICATIONS 6 Cyl. Engine CARBURETOR 250 Cu. In. 307 Cu. In. 350 Cu. In. 350 Cu. In. ENGINE DATA 1 Barrel 2 Barrel 2 Barrel 4 Barrel Horse power 155 @4200 200 @4600 250 @4800 300 @4800 Torque 235 @ 1...
[Page 87] Chevrolet station wagon 1970
FUSES AND CIRCUIT BREAKER: (Continued) The headlamp circuit is protected by a circuit breaker in the light switch. An overload on the breaker will cause the lamps to "flicker" on and off. If this condition de...
[Page 88] Chevrolet station wagon 1970
Recommendations for Filters, p.e.v. Valves, etc. ITEM USAGE RECOMMENDATION Engine Oil Filter AC Type PF24 L6, 307 cu. in. AC Type A169CW Engine Air Cleaner 350 cu. in. AC Type A358C Element 400 cu. in. AC Type A212CW 307,39...
[Page 89] Chevrolet station wagon 1970
INDEX Air Conditioning ........................ 26 Headlight Beam Switch ................. 19 Radiator ................................. 58 Air Vents (Astro Ventilation) ......... .40 Heater .......................... .. · ........
[Page 90] Chevrolet station wagon 1970
CHEVROLET ZONE OFFICE ADDRESSES Irondale, Ala. (Birmingham) 2300 Crestwood Blvd. 595·6121 Los Angeles, California 1800 Avenue of the Stars 879·9611 Oakland, California 10910 E. 14th St. 562,0553 San Diego, California 707 Bro...
[Page 91] Chevrolet station wagon 1970
CHEVROLET ZONE OFFICE ADDRESSES (Cont'd) Fargo, N. D. 701 Fourth Ave., N. 235·1101 Parma, Ohio (Cleveland) 12990 Snow Road (Parma) 265·5000 Sharonville, Ohio (Cincinnati) 11575 Reading Rd. 769·4100 Oklahoma City, Oklahpma...
Owner's manual (378 pages)
Owner's manual (514 pages)
Owner's manual (370 pages)
Owner's manual (374 pages)
Operation & user’s manual (20 pages)
Owner's manual (460 pages)