Daewoo DWF-1098 Service Manual

[Page 1] Daewoo DWF-1098

Service Manual Auto Washer Model: DWF-1098/1398/1068/1048 DAEWOO ELECTRONICS CO., LTD. ✔ Caution : In this Manual, some parts can be changed for improving, their performance without notice in the parts list. So, if you need the latest par...

[Page 2] Daewoo DWF-1098

AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUT WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHER AUTO WASHE AUTO W...

[Page 3] Daewoo DWF-1098

NO. ITEM DWF-1098 DWF-1068 DWF-1048 DWF-1398 1 POWER SOURCE AVAILABLE IN ALL LOCAL AC VOLTAGE AND CYCLE 2 POWER 50Hz 490W 500W CONSUMPTION 60Hz 550W 3 MACHINE NON-PUMP 47Kg(GROSS:50Kg) WEIGHT PUMP 49Kg(GROSS:52Kg) 4 DIMENSION(WXHXD) 630X1010X670 630X...

[Page 4] Daewoo DWF-1098

2. STRUCTURE OF THE WASHING MACHINE 3 STRUCTURE BUBBLE WASHING MACHINE • BLEACH INLET • HOT WATER TAP • POWER SWITCH • CONTROL PANEL • PULSATOR • ADJUSTABLE LEGS • GROUND WIRE In case of 3-wire power cord ground wire will not be p...

[Page 5] Daewoo DWF-1098

3. FUNCTIONS OF THE CONTROL PANEL 4 CONTROL PANEL • It can be used to choose water temperature to be supplied. • As the button is pressed, it will be repeated. COLD ➔ COLD + HOT ➔ HOT • In case of the single valve model, there is no wash ...

[Page 6] Daewoo DWF-1098

5 CONTROL PANEL BUBBLE WASHING MACHINE WATER LEVEL RES. WASH WASH SPIN SPIN REM. RES. COURSE ECO. ECO. START HOLD POWER RINSE RINSE COURSE FUZZY FEED SOCK BLANKET LIGHT HEAVY SUIT HOT COLD HIGHT MEDIUM LOW E.LOW DETERGENT WASH TEMP. HOUR MIN. MIN. ...

[Page 7] Daewoo DWF-1098

4. WASHING PROCEDURE AND COURSE SELECTION 6 PROCEDURE 1. FUZZY COURSE (SENSOR); • This selection is for general washing except extraordinary clothes. • Artificial brain sensor selects properly the various kind of washing condition such as washing...

[Page 8] Daewoo DWF-1098

7 PROCEDURE 5. HEAVY COURSE; • This selection is effective for blue-jean, climbing clothes, ruck sack, sports wear, etc ... • If you want to soak, press the “WASH” button to adjust to “SOAK” after the course selection. 6. ECONOMY COURSE; ...

[Page 9] Daewoo DWF-1098

5. DIRECTIONS FOR INSTALLATION AND USE 8 DIRECTIONS The openings must not be obstructed by carpet- ing when the washing machine is installed on a carpeted floor. ■ nstallation Of The Under Base Cover [Option] ■ How To Install On An Inclined P...

[Page 10] Daewoo DWF-1098

9 CONNECTION FOR ORDINARY TAP 6 Connect the inlet hose adapter of the hose to the water inlet of the washer by turning it clock- wise to be fixed tightly. • Please check the rubber packing inside the inlet hose adapter of the hose. 1 Pull down the ...

[Page 11] Daewoo DWF-1098

10 CONVENIENCE ■ How To Clean The Filter 4 Remove the dirt from the inlet filter with a brush. 1 Pull the power plug out before cleaning it. 2 Turn off the water supply to the washer and sperate the 3 Pull the inlet filter out. CLEANING THE LI...

[Page 12] Daewoo DWF-1098

6. FEATURE AND TECHNICAL EXPLANATION WASH DRAIN SPIN FILL RINSE 1 DRAIN SPIN FILL RINSE 2 DRAIN ••• MOTOR C.W SINGAL C.C.W TIME(SEC.) 0.3 0.3 0.3 0.3 0.3 0.3 •�...

[Page 13] Daewoo DWF-1098

12 EXPLANATION FUNCTIONAL PRINCIPLE 1 The micom can remember the time from the begining of drain to reset point when the pressure switch reaches to “OFF” point 2 In case of continuous draining, residual drain time is determined by micom. Draining...

[Page 14] Daewoo DWF-1098

13 EXPLANATION Contact of safety switch Lid closing Lid opening Contact lever A Normal (ON) Position of unbalanced load (OFF) Automatic Unbalance Adjustment Circulating-Water Course and Lint Filter The alarm finished when you close the lid after op...

[Page 15] Daewoo DWF-1098

14 EXPLANATION Much lint may be obtained according to the kind of clothes to be washed and some of the lint may also sticks to the clothes. To minimize this possibility a lint filter is provided on the upper part of the tub to filter the wash water a...

[Page 16] Daewoo DWF-1098

15 EXPLANATION The proper water currents is made by the rotation of pulsator at a low speed to prevent the damage to the small sized clothes. Pulsator shaft One way clutch bearing Brake lever Spin shaft Gear unit as Clutch spring Clutch boss Gear pul...

[Page 17] Daewoo DWF-1098

16 EXPLANATION ACROSS SECTION FUNCTIONAL PRINCIPLE Bubble generator supplies the air from the bottom of outer tub to the inner space of pulsator, the air is dispersed by the rotation of pulsator. Air-bubble is created by the centrifugal force, and ri...

[Page 18] Daewoo DWF-1098

17 DIRECTIONS 7. DIRECTIONS FOR DISASSEMBLY AND ADJUSTMENT ● Raise the top plate on the outer cabinet. ● Loosen four screws mounting outer tub cover and remove outer tub cover from the tub ass’y. ● Remove the spinner shaft flange nut by using...

[Page 19] Daewoo DWF-1098

18 DIRECTIONS ● Lay the front of the washer on the floor. ● Loosen the adjustment screw and four bolts mounting the drain motor. ● Take out the wire of drain motor from the bracket. ● Loosen the adjustment screw fastening the brack- et and pl...

[Page 20] Daewoo DWF-1098

19 TROUBLE SHOOTING 8. TROUBLE SHOOTING GUIDE PROBLEM WATER IS NOT SUP- PLIED. CHECK POINT Do you open the water tap? Is the filter of the water inlet valve clogged with dirt? Is the water pressure sufficient? (0.3~8 kgf/cm 2 ) Does the water inlet ...

[Page 21] Daewoo DWF-1098

20 TROUBLE SHOOTING PROBLEM WATER SUP- PLY IS NOT STOPPED. CHECK POINT Does the water supply continue while the power is turned off? Does the water supply start as soon as you press the power switch? Operate the washer after setting the water level t...

[Page 22] Daewoo DWF-1098

21 TROUBLE SHOOTING PROBLEM THE WASHER DOES NOT DRAIN. CHECK POINT Do you install the drain hose proper- ly? Is the foreign matter accumulated inside the pump housig? Is the output voltage of the drain pump nor- mal? CAUSE SOLUTION Install the drain ...

[Page 23] Daewoo DWF-1098

22 TROUBLE SHOOTING PROBLEM THE WASHER DOES NOT SPIN. CHECK POINT Is the lid open? Does the door switch operate normally? Does the safety switch operate normally? Does the pulsator rotate while the tub does not rotate? Is the connector of P.C.B ASS�...

[Page 24] Daewoo DWF-1098

23 TROUBLE SHOOTING NO NO NO PROBLEM THE INDICA- TOR LAMPS(L.E.D) DO NOT LIGHT UP WHEN THE POWER BUT- TON IS PRESSED. PROGRESS LAMPS(LED) DO NOT LIGHT UP. MOTOR ROTATES WHEN START/HOLD BUTTON IS NOT PRESSED. ABNORMAL NOISE DUR- ING WASH PROCESS. CHEC...

[Page 25] Daewoo DWF-1098

24 PCB ASS’Y 9. PRESENTATION OF THE P.C.B ASS’Y MESSAGE CAUSE SOLUTION Improper installation of drain hose. The drain hose is blocked up by foreign matter. Drai...

[Page 26] Daewoo DWF-1098

25 WIRING DIAGRAM APPENDIX ■ WRING DIAGRAM [Dwf-1098, 1398, 1068, 1048 non-pump] ...

[Page 27] Daewoo DWF-1098

26 WIRING DIAGRAM ■ [Dwf-1098, 1398, 1068, 1048 Non-Pump, Single Valve] ...

[Page 28] Daewoo DWF-1098

27 WIRING DIAGRAM ■ [Dwf-1098, 1398, 1068, 1048 Pump] ...

[Page 29] Daewoo DWF-1098

28 PARTS DIAGRAM ■ Parts Diagram ...

[Page 30] Daewoo DWF-1098

29 PARTS DIAGRAM ...

[Page 31] Daewoo DWF-1098

30 PARTS DIAGRAM ...

[Page 32] Daewoo DWF-1098

31 PARTS DIAGRAM ...

[Page 33] Daewoo DWF-1098

32 PARTS LIST ■ Parts List 1. DWF-1098, 1398, 1068, 1048 NO PARTS CODE PARTS NAME DESCRIPTION Q’TY REMARK A01 3619044100 SWITCH SAFETY DWF-1098 1 A02 5EP1048010 TRANS POWER T5-V1, AC 110-130V 1 5EP1048020 T5-V1F, AC 110-130C FUSE 5EP1048030 T5-...

[Page 34] Daewoo DWF-1098

33 PARTS LIST NO PARTS CODE PARTS NAME DESCRIPTION Q’TY REMARK A18 3611794500 DOOR F ABS 1 A19 3611504100 CUSHION DOOR CR 2 A20 3612604100 HANDLE DOOR PP 1 A21 3616008500 SPECIAL SCREW M5(T1)X10 1 A22 3610909700/10 CAP PLATE L/R ABS 1 A23 36113029...

[Page 35] Daewoo DWF-1098

34 PARTS LIST NO PARTS CODE PARTS NAME DESCRIPTION Q’TY REMARK B15 3617702100 LEG ADJUST SBR, PP 2 B16 3610808510 CABINET PAINTING, DWF-1094 1 B17 3611403710 COVER UNDER PP 1 “UP” MARKING B18 3613217800 HOSE DRAIN O PE-LD 1 PUMP B19 3618703760 ...

[Page 36] Daewoo DWF-1098

35 PARTS LIST NO PARTS CODE PARTS NAME DESCRIPTION Q’TY REMARK D01 3611410400 COVER TUB O PP 1 DWF-1098/68 3611413900 PP DWF-1398 D02 3618807100 TUB O PP 1 DWF-1098/68 3618807120 PP, PUMP DWF-1098/68, PUMP 3618807110 PP DWF-1398 D03 3618101400 NOZZ...

[Page 37] Daewoo DWF-1098

36 PARTS LIST NO PARTS CODE PARTS NAME DESCRIPTION Q’TY REMARK D17 3618401400 PULLEY MOTOR AS ADC-12, DS=10, DP=48.5 1 60Hz 3618401420 ADC-12, DS=10, DP=53.0 50Hz D18 3611502000 CUSHION UPPER POM 107X31X6.7 2 D19 7650802811 BOLT HEX 6B-1 8X28 HS MF...

[Page 38] Daewoo DWF-1098

37 CIRCUIT DIAGRAM ■ DWF-1098, 1398 Circuit Diagram ...

[Page 39] Daewoo DWF-1098

38 CIRCUIT DIAGRAM ■ DWF-1068, 1048 Circuit Diagram ...

[Page 40] Daewoo DWF-1098

...

[Page 41] Daewoo DWF-1098

S/M NO. : WF1098SE01 DAEWOO ELECTRONICS CO., LTD. 686, AHYEON-DONG MAPO-GU SEOUL, KOREA C.P.O. BOX 8003 SEOUL, KOREA TELEX: DWELEC K28177-8 CABLE: “DAEWOOELEC” FAX: 02) 590-6291 TEL: 02) 360-7114/590-6151~5 http://www.dwe. daewoo.co.kr PRINTED DA...